Red Lion XCGSM - Manual

 CONFIGURED USING CRIMSON ® SOFTWARE
 INSTALLS INSIDE A DATA STATION PLUS OR A MODULAR
CONTROLLER
 INSTALLATION AND CONNECTION HARDWARE ARE INCLUDED
WITH CARD
GENERAL DESCRIPTION
The XCGSM option card allows the user to add GSM/GPRS cellular modem
capability to their Data Station Plus or Modular Controller. GSM/GPRS is the
most prevalent cellular technology in today’s markets. GPRS can be used for
services such as Wireless Application Protocol (WAP) access, Short Message
Service (SMS), and for Internet communication services such as email and
World Wide Web access. The XCGSM modem option card is quad-band,
allowing it to work in frequencies across the Americas, Europe and Asia. US
and Canada work in the 850/1900 MHz bands, while Europe, Middle East,
Africa and most of Asia work in the 900/1800 MHz GSM/GPRS frequencies.
The XCGSM requires the addition of a SIM (Subscriber Identity Module)
card, which is inserted into the holder prior to installation of the XCGSM card.
The SIM card securely stores the service-subscriber key (IMSI) used to identify
a subscriber, and is used to connect to the network to obtain an IP address from
the provider.
The XCGSM communication card is easily installed by removing the blank
expansion port cover of your Modular Controller or Data Station Plus, and
plugging the XCGSM card into the expansion port. Configuration is simple
using Red Lion’s free Crimson
® 2.0 software.
SAFETY SUMMARY
All safety related regulations, local codes and instructions that appear in the
literature or on equipment must be observed to ensure personal safety and to
prevent damage to either the instrument or equipment connected to it. If
equipment is used in a manner not specified by the manufacturer, the protection
provided by the equipment may be impaired.
Do not use the controller to directly command motors, valves, or other
actuators not equipped with safeguards. To do so can be potentially harmful to
persons or equipment in the event of a fault to the controller.
ORDERING INFORMATION
MODEL NO. DESCRIPTION PART NUMBER
XCGSM GSM/GPRS Cell Modem Option Card XCGSM000
ANT Quad band GSM/GPRS Cellular antenna 1 G3QANT00
SFCRM2 Crimson 2.0 with G3/Data Station Manual 2 SFCRM200
SFCRM2 Crimson 2.0 with Modular Controller Manual 2 SFCRM2MC
1 G3QANT00 is a 6 inch direct mount Quad-band antenna.
2 Use these part numbers to purchase Crimson 2.0 on CD with a printed
manual, USB cable and RS-232 cable. Otherwise, download free of charge
from www.redlion.net.
CONTENTS OF PACKAGE
- XCGSM option card
- This hardware bulletin
SPECIFICATIONS
1. POWER REQUIREMENTS: 24 V @ 125 mA max. Power is supplied to
the option card from the main board of the Modular Controller Master or
Data Station Plus.
2. ANTENNA CONNECTOR:
SMA Female connector requires:
50 Ohm antenna with SMA male connector
Quad-band antenna (850/900/1800/1900 MHz) for global support.
Dual-band (850/1900 MHz) antenna for US and Canada only
Dual band (900/1800 MHz) for Europe only
The antenna cable should be 50
 impedance, RG178/U or RG174/U type
and be able to connect to the RSMA (Male) jack bulkhead. The antenna
could be horizontal, vertical or right angled. Longer antenna cable would
equate to signal loss.
This device is intended for connection to an antenna mounted within the
building or a UL certified enclosure suitably rated for application.
3. CERTIFICATIONS AND COMPLIANCES:
Refer to main unit manual or “Agency Approvals” section of Red Lion’s
website for agency certifications.
ELECTROMAGNETIC COMPATIBILITY
Emissions and Immunity to EN 61326: Electrical Equipment for
Measurement, Control and Laboratory use.
Reference Modular Controller Master or Data Station Plus unit for EMC
specifications
The XCGSM option card has been tested and found to comply with the limits
for a Class A digital device, pursuant to part 15 of the FCC rules.
4. ENVIRONMENTAL CONDITIONS:
Refer to the specifications of the Modular Controller Master or Data Station
Plus you are installing this card in.
5. CONSTRUCTION: For indoor use only. Installation Category II, Pollution
Degree 2.
6. INSTALLATION REQUIREMENTS: See “Installing the XCGSM Option
card” for more details.
7. WEIGHT: 3.2 oz (94.64g)
MODEL XCGSM – GSM/GPRS CELLULAR MODEM OPTION CARD FOR
DATA STATION PLUS AND MODULAR CONTROLLER
Bulletin No. XCGSM- A
Drawing No. LP0782
Released 02/10
Tel +1 (717) 767-6511
Fax +1 (717) 764-0839
www.redlion.net
CAUTION: Risk of Danger.
Read complete instructions prior to
installation and operation of the unit.
1