Star Water Systems SJ05SAT20H User Manual

Page 8

PUMP PRIMING AND STARTUP

5. Once pump/tank is filled, wrap the pressure

gauge or discharge tee plug and vent plug

threads with thread tape and thread into

pump/tank. Tighten with wrench.

NOTE: Before turning on breaker, open several

outlets or faucets to allow water flow during

priming.

Vent Plug

Pressure

Gauge or

Discharge

Tee Plug

IL1339

Breaker Box

6. Turn on breaker to start pump/tank.

IMPORTANT: If pump/tank hums instead

of pumping or turns off repeatedly, shut pump

off immediately. Check voltage. Make sure

your incoming voltage matches pump/tank

wiring voltage. See PUMP ELECTRICAL

CONNECTIONS.

IMPORTANT: If pump/tank fails to prime

within five minutes:

Turn power off at the breaker box and check all

pipe connections for leaks. All connections must

be water and air tight in order for pump/tank to

operate.

7. Check suction pipe for any sagging. Support

suction pipe in a straight line to pump/tank.

NOTE: Look for leaks or a milky color in the

discharged water, which indicates an air leak.

Re-prime if necessary, following steps 1 through

6 above. Reset breaker at the breaker box. All

connections must be water and air tight in order

for pump/tank to operate.

1 in. Discharge Pipe

Discharge to

Home

1-1/4 in.

Suction

Pipe
Foot Valve

Well

CARE AND MAINTENANCE

Winterizing

CAUTION: Drain the entire system if

there is danger of freezing.

1. To drain pump/tank, remove the drain plug

located on the front of pump/tank and the

vent plug located on the top of pump/tank.

Vent Plug

Drain

Plug

WARRANTY

This product is warranted for one year from

the date of purchase or two years from the

date of manufacture, whichever occurs first.

Subject to the conditions hereinafter set forth,

the manufacturer will repair or replace to the

original consumer, any portion of the product

which proves defective due to defective materials

or workmanship. To obtain warranty service,

contact the dealer from whom the product

was purchased. The manufacturer retains the

sole right and option to determine whether to

repair or replace defective equipment, parts or

components. Damage due to conditions beyond

the control of the manufacturer is not covered by

this warranty.
THIS WARRANTY WILL NOT APPLY: (a) To

defects or malfunctions resulting from failure to

properly install, operate or maintain the unit in

accordance with printed instructions provided;

(b) to failures resulting from abuse, accident or

negligence or use of inappropriate chemicals or

additives in the water; (c) to normal maintenance

services and the parts used in connection with

such service; (d) to units which are not installed

in accordance with normal applicable local codes,

ordinances and good trade practices; and (e) the

unit is used for purposes other than for what it

was designed and manufactured.
RETURN OF WARRANTED COMPONENTS:

Any item to be repaired or replaced under this

warranty must be returned to the manufacturer at

Kendallville, Indiana or such other place as the

manufacturer may designate, freight prepaid.

THE WARRANTY PROVIDED HEREIN IS IN

LIEU OF ALL OTHER EXPRESS WARRANTIES,

AND MAY NOT BE EXTENDED OR MODIFIED

BY ANYONE. ANY IMPLIED WARRANTIES

SHALL BE LIMITED TO THE PERIOD OF THE

LIMITED WARRANTY AND THEREAFTER

ALL SUCH IMPLIED WARRANTIES ARE

DISCLAIMED AND EXCLUDED. THE

MANUFACTURER SHALL NOT, UNDER

ANY CIRCUMSTANCES, BE LIABLE FOR

INCIDENTAL, CONSEQUENTIAL OR SPECIAL

DAMAGES, SUCH AS, BUT NOT LIMITED

TO DAMAGE TO, OR LOSS OF, OTHER

PROPERTY OR EQUIPMENT, LOSS OF

PROFITS, INCONVENIENCE , OR OTHER

INCIDENTAL OR CONSEQUENTIAL DAMAGES

OF ANY TYPE OR NATURE. THE LIABILITY OF

THE MANUFACTURER SHALL NOT EXCEED

THE PRICE OF THE PRODUCT UPON WHICH

SUCH LIABILITY IS BASED.
This warranty gives you specific legal rights, and

you may have other rights which vary from state

to state. Some states do not allow limitations

on duration of implied warranties or exclusion

of incidental or consequential damages, so the

above limitations may not apply to you.
FOR YOUR WARRANTY PROTECTION,

THE WARRANTY REGISTRATION MUST

BE COMPLETED AND RETURNED TO THE

WARRANTY INFORMATION CENTER WITHIN

TEN DAYS OF INSTALLATION. WARRANTY

VALID IN CANADA AND MEXICO.