Banks Power Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) PowerPack & Stinger w_EconoMind '06-07 For use with PowerPDA User Manual
Page 10

10
96813 v.9.0
18.
Move the spare-tire to the rear
of the vehicle and center between
the dual tailpipes. Tighten the spare
tire with the manufacture tire tool
so that it is retained into place (See
Figure 5).
19.
Un-clip the axle vent hose outlet
attached to the bed near the spare
tire. Re-route the vent hose on top of
the fuel tank and attach to the bed.
Zip tie the vent hose and brake line
to the emergency brake cable, away
from the tailpipe.
20.
Adjust each of the pipes to
ensure that all of the hanger pins
are parallel with the frame-mounted
pins and fully inserted in the vehicle’s
rubber hangers.
21.
Be sure that the two (2) tailpipes
are completely engaged into the
Y-pipe. Rotate the tailpipe until the
hanger pins are parallel with the
frame-mounted pin.
NOTE: Recommended distance
between exhaust tip and body is a
half (
1
⁄
2
”) inch.
22.
Beginning with clamps closest
to the catalytic converter, and
working your way back, align the
saddle clamps to on the radius of
the corresponding pipe slots. Figure
3 illustrates the proper location of
an exhaust clamp on a tubing joint.
Evenly torque the nuts on each of the
exhaust clamps to 35 ft-lb.
Note: Whenever possible, tack
weld slip connections to prevent
disengagement is recommended.
23.
Remove the protective covering
from the tailpipe tip. Caution: the
protective covering may ignite
and burn if not removed prior to
running the engine.
-END, SEcTION 1-
BANKS
DRIVER SIDE
TAILPIPE
ZIP TIE ON
VENT HOSE
& BRAKE LINE
BANKS
PASSENGER SIDE
TAILPIPE
ADJUST SO THAT
SPARE TIRE TO
TAILPIPE CLEARANCE
IS THE SAME
MOVE SPARE
TIRE TOWARDS
REAR OF
VEHICLE
Figure 5
- Ford Trucks: (Diesel ’94 - 97 7.3L Power Stroke) Tuner- Big Hoss Module (6 pages)
- Ford Trucks: (Diesel ’03 - 07 6.0L Power Stroke) Intake- Ram-Air Intake system '03-07 F-250-350-450 pickup (20 pages)
- Ford Trucks: (Gas ’04 - 08 F-150 V6 & V8) Exhaust- Monster Exhaust, Dual out the back exit '04-10 F-150 4.2L, 4.6L & 5.4L (Non-Heritage models) (12 pages)
- Ford Trucks: (Diesel ’99 - 03 7.3L Power Stroke) Forced Induction- Big Head Wastegate Actuator '99-03 F-250 & F-350 pickup (4 pages)
- Chevy_GMC Trucks: Duramax LLY (Diesel ’04 - 05 6.6L) Speed Control- Banks Brake w_ Switch (20 pages)
- Toyota Trucks: (Gas ’05 - 12 4.0L Tacoma) Exhaust- Monster Exhaust, Single side exit 2013 Toyota Tacoma 4.0L (8 pages)
- Chevy_GMC Trucks: Duramax LLY-LBZ (Diesel ’06 - 07 6.6L) Tuner- Six-Gun Diesel Tuner '06 -07 (PDA) Compatible with Optional PowerPDA & Speed-Loader (28 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Exhaust- Monster Exhaust, Single out the back '04-07 325 HP Dodge 5.9L HO Cummins Trucks, Including Mega Cab (8 pages)
- Dodge Trucks: (Diesel ’07 - 12 6.7L Cummins) Exhaust- Monster Exhaust, Split-Dual Quad Tip ,side exit '07-09 Including Mega Cab (12 pages)
- Ford Trucks: (Diesel ’03 - 07 6.0L Power Stroke) Exhaust- Monster Exhaust, Single Passenger side exit, F-250_F-350 '03-07 Pickup Trucks and Excursions (16 pages)
- Dodge Trucks: (Gas ’02 - 10 5.7L HEMI & 4.7L) Exhaust- Monster Exhaust '06-08 Ram 1500 Hemi ('06-08) RCSB_CCSB_CCLB & ('06-07) Mega Cab (8 pages)
- Ford Trucks: (Diesel ’99 - 03 7.3L Power Stroke) Intake- Ram-Air Intake System '99-03 (16 pages)
- Dodge Trucks: (Diesel ’94 - 98 5.9L Cummins) Intake- Ram-Air Intake System '98-02 (12 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Tuner- Six-Gun Diesel Tuner w optional Speed-Loader Module, (325 HP Dodge 5.9L Cummins 600 (24-valve) Trucks) '04-05 For use with Six-Gun Switch (28 pages)
- Ford Trucks: (Diesel ’08 - 10 6.4L Power Stroke) Exhaust- Monster Exhaust, Single Passenger side exit '08-10 F-250_ F-350 (16 pages)
- GM Motorhomes: (Gas ’01 - 10 8.1L Workhorse) PowerPack & Stinger systems '01-04 Class-A MH, P-series (14 pages)
- Ford Trucks: (Gas ’09 - 12 F-150 5.0, 5.4 & 6.2L) Exhaust- Monster Exhaust, Single Passenger side exit '09-10 F-150 5.4L SuperCrew Cab & F-150 Raptor 6.2L SuperCab (8 pages)
- Chevy_GMC Trucks: Duramax LB7 (Diesel ’01 - 04 6.6L) Speed Control- Compressor Relocation Kit Required for Ram-Air Intake System (8 pages)
- Ford Trucks: (Diesel ’94 - 97 7.3L Power Stroke) Speed Control- Banks Exhaust Brake '94-97 (16 pages)
- Ford Trucks: (Diesel ’03 - 07 6.0L Power Stroke) Interface- PowerPDA Ford (03-09), Chevy (01-08), Dodge (03-07) (44 pages)
- Chevy_GMC Trucks: Duramax LB7 (Diesel ’01 - 04 6.6L) Power Systems- PowerPack & Stinger Systems w_ EconoMind (LB7 & LLY) '01-05 (PDA) Compatible w_ Optional PowerPDA (45 pages)
- Ford Trucks: (Diesel ’08 - 10 6.4L Power Stroke) Tuner- Six-Gun Diesel Tuner & SpeedBrake, For use with Banks iQ '08-10 Compatible with PowerPDA (36 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Intake- High-Ram Intake '03-07 w_Banks Boost Tube (12 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) PowerPack & Stinger w_EconoMind '03-05 For use with PowerPDA (40 pages)
- Ford Trucks: (Diesel ’08 - 10 6.4L Power Stroke) Intake- Ram-Air Intake System '08-10 F-250_ F-350_ F-450 (16 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Tuner- Six-Gun Diesel Tuner (235, 250, 305 HP Dodge 5.9L Cummins (24-valve) Trucks) '03-04 For use with Six-Gun Switch (36 pages)
- Ford Trucks: (Gas ’87 - 97 7.5L EFI) Power Systems- Stinger system '87-96 SC, EC & CC (For Use w_ 460 EFI Engine) (8 pages)
- Cummins Motorhomes: (Diesel ’93 - 98 B5.9L & C8.3L) PowerPack & Stinger systems w_Twin Ram Manifold 5.9L, 190-210-230-hp rated (20 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Intake- Techni-Cooler Charge Air Cooler ('03-07) (12 pages)
- Chevy_GMC Trucks: Gas ’99 - 14 4.3,4.8,5.3,6.0,6.2,8.1 Exhaust- Torque Tubes System '99-08 GM 4.8L, 5.3L, 6.0L & '09-10 GM 5.3L Pickups & SUVs (8 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Intake- High-Ram Air Intake '03-07 (12 pages)
- Dodge Trucks: (Diesel ’94 - 98 5.9L Cummins) Power Systems- Git-Kit; '94-97 (1 page)
- Chevy_GMC Trucks: Duramax LB7 (Diesel ’01 - 04 6.6L) Tuner- Six-Gun Diesel Tuner with optional Speed-Loader Module '01-04 For use with Six-Gun Switch (24 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Speed Control- Banks Brake with CBC-SmartLock '04-07 (52 pages)
- Chevy_GMC Trucks: Diesel ’93 - 96 6.5L Power Systems- Stinger System '93-early '94 (non-cat) Pickups w_ factory turbo option (10 pages)
- Ford Trucks: (Diesel ’03 - 07 6.0L Power Stroke) Tuner- Six-Gun Diesel Tuner w_ optional Speed-Loader Module For use with Six-Gun switch Only (28 pages)
- Ford Trucks: (Diesel ’11 - 14 6.7L Power Stroke) Exhaust- Monster Exhaust, Split-Dual, side exits '11 F-250_ F-350_ F-450 (12 pages)
- Dodge Trucks: (Diesel ’98 - 02 5.9L Cummins ISB) Tuner- Big Hoss Diesel Tuner (does not connect to pump wire) (16 pages)
- Ford Trucks: (Diesel ’03 - 07 6.0L Power Stroke) Power Systems- PowerPack & Stinger '03-07 Compatible w_ Optional Banks iQ (42 pages)
- Ford Trucks: (Diesel ’83 - 93 6.9 & 7.3L) Forced Induction — Sidewinder Turbo System (1st Generation) 6.9_7.3L Ford (39 pages)
- Dodge Trucks: (Diesel ’07 - 12 6.7L Cummins) Exhaust- Monster Exhaust, Split-Dual, side exits '07-10 including Mega Cab (12 pages)
- Ford Trucks: (Diesel ’99 - 03 7.3L Power Stroke) Exhaust- Monster Exhaust, Single Passenger side exit (w_ cat) '99-03 F-250 & F-350 (20 pages)
- Chevy_GMC Trucks: Duramax LB7 (Diesel ’01 - 04 6.6L) Intake- Ram-Air Intake Super-Scoop '03-07 (12 pages)
- Dodge Trucks: (Diesel ’98 - 02 5.9L Cummins ISB) Intake- Heater Delete Kit '98-07 (1 page)