Vortech 1997-2001 5.2L/5.9L Durango/Dakota User Manual

Page 27

P/N: 4CE020-010

18AUG00 V 2.1

(Dodge 5.9L Durango/Dak-2)

14. FINAL CHECK

A. Reconnect the battery.
B. If your vehicle has gone over 10,000 miles

since its last spark plug change, you will
need to change the spark plugs now be-
fore test driving the vehicle.

C. Check all fittings, nuts, bolts and clamps

for tightness. Pay particular attention to oil
and fuel lines around moving parts, sharp
edges and exhaust system parts. Make
sure all wires and lines are properly se-
cured with clamps or tie wraps. (See

Fig-

ure 14-a

D. Check all fluid levels, making sure that

your tank(s) is/are filled with 92 octane or
higher fuel before commencing test drive.

E. Start engine and allow to idle a few min-

utes, then shut off.

F. Recheck to be sure that no hoses, wires,

etc. are near exhaust headers or moving
parts and check for signs of any fluid
leakage. Check ignition timing to make
sure it is set to stock specifications before
commencing test drive.

G. PLEASE TAKE SPECIAL NOTE: Oper-

ating the vehicle without

ALL

the subas-

semblies completely and properly installed
may cause FAILURE OF MAJOR COM-
PONENTS.

H. Test drive the vehicle.
I.

Read the STREET SUPERCHARGER
SYSTEM OWNER'S MANUAL AND RE-
TURN THE WARRANTY REGISTRA-
TION FORM within thirty (30) days of
purchasing your supercharger system.

WARNING: Do not attempt to operate the ve-

hicle until ALL components are in-
stalled and ALL operations are
completed including the final
check.

Figure: 14-a

This manual is related to the following products:

1996-2001 5.2L/5.9L Ram