American Energy Systems MagnuM Baby Countryside - Manual (Page 29)

29
auger will stop feeding. However, the blowers will continue to run until the POP switch has
cooled down to initiate the shut down cycle.
Your Magnum Wood Pellet Stove comes to you with the glass door installed in place, ready for use. The glass is
surrounded on the edges with a gasket and seated in a glass channel. It is held in place with two (2) clips on the top
and two (2) clips on the bottom
REMOVAL OF BROKEN OR DAMAGED GLASS
Open the door and lift off of hinges. If the door is tight, tap gently on the bottom of the door with your hand or
rubber hammer. Lay door down on newspaper with glass clips facing you. Using a #2 Phillips screwdriver, loosen
the screws and take off the glass clips. Remove the broken glass carefully and discard. Check to make sure that the
gasket material under the glass is in good shape. You can get this material from the factory or from an authorized
Magnum reseller if it needs to be replaced.
Reverse the above procedure for replacing new glass. When installing the new glass make sure that the glass is
not sitting on top of any obstruction. The glass will break when tightening the screws if the glass is on the
gasket. Hold the glass toward the top of the door glass channel when tightening.
CLEANING THE GLASS
When the fire is first started, it will produce some smoke. The smoke might accumulate on the glass surface.
Before the fire gets hot, open the door and wipe the glass surface off with a damp rag. Do not touch the surface
with your hands. If after constant use, the glass is dirty; you must clean the glass so that it will not become etched
with the fly-ash. When the glass has cooled off, take a damp rag, put a little fly- ash from the unit on it and clean
the glass. If this does not clean the glass use a special glass cleaner provided by your Magnum reseller. We have
found that Amway crème glass & chrome cleaner works real well.
GLASS MAINTENANCE, ADJUSTMENT, REMOVAL AND REPLACEMENT
WARNING
Do no operate unit with broken glass.
Do not substitute original factory glass.
You must use only factory authorized glass:
(8.984 x 12.563
”
high temperature Ceramic glass, 5mm thick)
Do not slam door shut.
Do not strike glass.
Do not use abrasive cleaners.
Do not clean when glass is hot.
GLASS CLIPS