Troy-Bilt 1900678 - Manual (Page 34)

C. Disconnect the negative (-) cable from the negative
battery post and remove the cable.
D. Disconnect the positive (+) cable from the positive
battery post (leave the other end connected to the sole­
noid). Cover the loose end of the cable with the rubber
boot.
E. Remove the battery hold-down clamp and remove
the battery.
F. Reverse the above steps when replacing the battery.
STARTING THE ELECTRIC START
ENGINE WITH THE RECOIL STARTER ROPE
If necessary, the electric start engine can be started
with the recoil starter rope. However, before doing so
be sure to follow the procedure below that applies to
your particular situation.
A. If the battery is in good condition (not “dead” or
damaged), you can leave it on the mower which allows
it to be recharged during engine operation. But, before
starting the engine with the recoil rope, make sure that
the battery is filled to the UPPER LEVEL with electro­
lyte and that all of the cables and wires are properly
connected.
B. If the battery is “dead” or damaged, then it should
be removed from the mower and tested by a qualified
battery mechanic. While the battery is removed, keep
the loose terminal on the positive battery cable covered
with a wrapping of electrical tape and secure the cable
to the frame of the mower. Taping over the terminal will
prevent any possibility of sparking from the cable termi­
nal.
IMPORTANT
When starting the engine with the recoii starter rope,
the key switch must first be piaced in the RUN position
and the engine throttle lever in the CHOKE position.
ENGINE MAINTENANCE
IMPORTANT
Perform only the routine engine maintenance described
here and in the engine owner’s pamphlet. For other
maintenance and parts, contact an authorized Briggs &
Stratton Service Dealer. Any unauthorized work done
on the engine during the warranty period may void your
warranty. For full details on the engine manufacturer’s
limited warranty, please see the separate engine owner’s
pamphlet. (If you have any difficulty in finding an author­
ized dealer or in obtaining warranty service, please con­
tact the Garden Way Technical Service Department for
assistance.)
H CAUTION: To avoid persona- injury, stop the
engine, disconnect the spark plug wire, keep
the wiro away from the spark plug, and allow the
eng-ne and muffler to cool before inspect ng or
servicing the engine.
ENGINE CRANKCASE OIL
It is vitally important that you use motor oil of the pro­
per service grade and viscosity, and that you regularly
check and change the oil according to the recommend­
ed hours of operation. Incorrect, insufficient, or dirty oil
will cause premature engine wear and damage.
A. Check the oil level before each use and after each
5 hours of continuous operation. Do not run the engine
unless the proper oil level is maintained. See Section 2
for detailed instructions.
B. Change the oil after the first 5 hours of operation
and every 25 hours thereafter. Change the oil more fre­
quently in extremely dusty or dirty conditions. Refer to
your
engine owner’s pamphlet for oil changing
instructions.
IMPORTANT
Your engine has been equipped with an extended oil
drain pipe. See Photo 5-27 or 5-28.
Photo 5-27: Oil drain on 5 HP engine.
_______________________ ; Photo 5-28: Oil drain on 8 HP engine.
32