Reznor Q6SE Unit Installation Manual - Manual (Page 2)

2
InStAllER InFoRMAtIon
USER InFoRMAtIon
IMPoRtAnt SAFEtY InFoRMAtIon ....................5
GEnERAl InFoRMAtIon .......................................6
Before you install this unit ......................................6
Locating the Heat Pump .........................................6
Field Connections for Electrical Power Supply .......6
Air Ducts .................................................................6
Unconditioned Spaces ........................................6
Acoustical Duct Work ..........................................6
Air Filter Requirements...........................................7
HEAt PUMP InStAllAtIon ..................................7
Packaging Removal ................................................7
Rigging & Hoisting ..................................................7
Minimum Clearances ..............................................7
Ground Level ..........................................................7
ElEctRIcAl WIRInG .............................................8
Pre-Electrical Checklist:..........................................8
Line Voltage ............................................................8
Rooftop ...................................................................8
Horizontal to Downflow Conversion ........................8
Condensate Drain ..................................................8
Grounding...............................................................9
Blower Speed .........................................................9
Thermostat Connections ........................................9
Defrost Cycle Timer ................................................10
Demand Defrost Control.........................................10
Optional Outdoor Thermostat .................................10
Optional Electric Heater Kits ..................................10
StARt UP & ADjUStMEntS .................................11
Pre-Start Check List ...............................................11
Start-Up Procedure ................................................11
Air Circulation ......................................................11
Short Cycle Protection ........................................11
System Cooling ...................................................11
System Heating ...................................................11
REFRIGERAnt cHARGInG ....................................11
HEAt PUMP MAIntEnAncE ..................................12
Charging an R-410A Unit in AC Mode ...................12
Charging an R-410A Unit in Heating Mode. ...........12
REPlAcEMEnt PARtS ..........................................12
FIGURES & tABlES ................................................13
Figure 6. Q6SE Heat pump Dimensions .............13
Table 4. Center of Gravity & Unit Shipping
Weights..................................................13
Electrical Information ..............................................14
Figure 7. Typical Heat Pump Thermostat
Connections 208V / 230V.....................14
Figure 8. Wiring Diagram for 208/230V Units ......15
Cooling Charging Charts ........................................16
Figure 9. Charging Chart for 2 Ton Units .............16
Figure 10. Charging Chart for 2.5 Ton Units ........16
Figure 11. Charging Chart for 3 Ton Units ...........17
Figure 12. Charging Chart for 3.5 Ton Units ........17
Figure 13. Charging Chart for 4 Ton Units ...........18
Figure 14. Charging Chart for 5 Ton Units ...........18
Airflow Data ............................................................19
Table 5. Q6SE Airflow Data .................................19
InStAllAtIon / PERFoRMAncE cHEcKlISt ...20
IMPoRtAnt SAFEtY InFoRMAtIon ....................3
ABoUt tHE HEAt PUMP .......................................3
oPERAtInG InStRUctIonS .................................3
Cooling Operation ..................................................3
Heating Operation ..................................................3
Emergency Heat.....................................................3
Defrost Operation ...................................................3
HEAt PUMP MAIntEnAncE ..................................4
Regular Cleaning....................................................4
tRoUBlESHootInG ..............................................4
WARRAntY InFoRMAtIon ...................................4
Operating the Heat Pump for Automatic Cooling and
Heating ...................................................................4
Operating the Indoor Blower Continuously .............4
Shutting the Heat Pump Off ...................................4