Multiquip MQ600TD80 - Manual (Page 11)

mq600Td80 TRaSH pUmp• opeRaTion and paRTS manUal — Rev. #11 (10/10/11) — page 11
saFety inFOrMatiOn
baTTeRy SaFeTy (eleCTRiC STaRT only)
dangeR
„ do noT drop the battery. There is a possibility that the
battery will explode.
„ do noT expose the battery to open fl ames,
sparks, cigarettes, etc. The battery contains
combustible gases and liquids. If these
gases and liquids come into contact with a
fl ame or spark, an explosion could occur.
WaRning
„ alWayS wear safety glasses when
handling the battery to avoid eye irritation.
The battery contains acids that can cause
injury to the eyes and skin.
„ Use well-insulated gloves when picking up
the battery.
„ alWayS keep the battery charged. If the battery is not
charged, combustible gas will build up.
„ do noT charge battery if frozen. Battery can explode.
When frozen, warm the battery to at least 61°F (16°C).
„ alWayS recharge the battery in a well-ventilated
environment to avoid the risk of a dangerous concentration
of combustible gases.
„ If the battery liquid (dilute sulfuric acid)
comes into contact with clothing or skin,
rinse skin or clothing immediately with
plenty of water.
„ If the battery liquid (dilute sulfuric acid) comes into
contact with eyes, rinse eyes immediately with plenty
of water and contact the nearest doctor or hospital to
seek medical attention.
CaUTion
„ alWayS disconnect the negaTive battery terminal
before performing service on the equipment.
„ alWayS keep battery cables in good working condition.
Repair or replace all worn cables.
TRanSpoRTing SaFeTy
CaUTion
„ NEVER allow any person or animal to stand underneath
the equipment while lifting.
NOTICE
„ Before lifting, make sure that the equipment parts are not
damaged and screws are not loose or missing.
„ alWayS make sure forklift forks are inserted into pockets
(if applicable) as far as possible when lifting the pump.
„ alWayS shutdown engine before transporting.
„ neveR lift the equipment while the engine is running.
„ Tighten fuel tank cap securely and close fuel cock to
prevent fuel from spilling.
„ Use one point suspension hook and lift straight upwards.
„ do noT lift machine to unnecessary heights.
„ alWayS tie down equipment during transport by
securing the equipment with rope.
„ Never allow any person or animal to stand underneath the
equipment while lifting.