JLG 80H ANSI Parts Manual - Manual (Page 222)

2-132 3120272
SECTION 2 TURNTABLE S
E
C
T
I
O
N
2
T
U
R
N
T
A
B
L
E
307 (cont’d) 7023471 Float Assembly 1
Use 7019988
Engines - 2000153 & 2000157 (was p/n
7019974)
7019988 Engine - 2000159
7024321 Gasket, Carburetor (Top)
70000163 Needle, Spring Loaded
7016605 Choke, Automatic
7019933 Rebuilt Kit - Carburetor
Use 70000646 Gasket, Carburetor (was p/n 7019975)
7025122 Base, Carburetor 1
7027292 Float Assembly 1
308 7019976 Flywheel Housing and Coupling Assembly 1
7022180 Ring Gear (Not Shown) 1
7020120 Housing, Bell (Engine - 2000126) 1
309 Use 1660249 Coupling (was p/n 7012656) 1
310 Use 7019926 Hose, Radiator (Top) (was p/n 7016375) 1
311
Use 7019927
Hose, Radiator (Bottom) (was p/n
7016376)
1
312 Water Pump Assembly Options (Not Shown): 1
7022153 LRG-423 Engine (was p/n 7016638) 1
7022153 LRG-425 Engine 1
7019985 Pulley, Water Pump (LRG-425 Engine) (Not
Shown) 1
7019982 Inlet, Water Pump (Not Shown) (Engines -
2000153, 2000157, 2000159) 1
7022156 Thermostat Assembly (Not Shown) (Engine -
2000159) 1
313 7022143
Exhaust Manifold to Head Gasket (Engine -
2000126) (Not Shown - Located on opposite side
of engine)
1
314 70002307 Exhaust Manifold to Exhaust Pipe 1
315
2420109
Dipstick (Engine - 2000159) 1
4564281 Tube, Dipstick 1
316 Use7025126 Manifold, Intake (was p/n 7019923) 1
317 7019924 Manifold, Exhaust (Not Shown) 1
318 7019930 Coil, Ignition (Engines - 2000126 & 2000159) 1
7019931 Wire Set - Spark Plug 1
7019932 Plug, Spark 4
319 Belt, Drive Options: 1
7019921 Engine - 2000126 1
Use 7027402 Engines - 2000153, 2000157 & 2000159
(was p/n 7019979) 1
Tensioner, Belt Options (Not Shown): 1
7019929 Engine - 2000126 1
7019978 Engines - 2000153, 2000157 & 2000159 1
320 7022139 Sensor, MAP (Not Shown) (Engine - 2000159) 1
321
7022178 Sensor, Crank Shaft (Not Shown) (Engines -
2000126 & 2000159) 1
322
7025134 Gasket, Water Outlet Connector (Not Shown)
(Engine - 2000159) 1
323 7019925 PCV Valve (Not Shown) (Engine - 2000126) 1
FIGURE 2-33. FORD LRG423/LRG425 ENGINE INSTALLATION (MARCH 1995 TO PRESENT)
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.