Table 3, 15 - apollo gate opener troubleshooting table 2, 14 - maintenance schedule - apollo gate opener – Controlled Products Systems Group 1550ETL-1K User Manual
Page 29
29
TABLE 3
SYMPTOM(S) POSSIBLE
SOLUTION
Operator will not power
On.
Power LED is OFF
x
Check terminal Lock wiring for loose or broken wires
x
Check the fuse
x
Check wiring polarity
Gate opens a short dis-
tance, then stops and
reverses
x
Check the UL/Edge input on the gate controller
x
Adjust Force Settings
x
Check Motor 1 and Motor 2 encoder LEDs to verify the LEDs toggle when
the gate is moving
Gate opens but will not
close
x
Check the input LEDs. Any ON will hold the gate open and indicates a
problem with a keying device
x
Check the secondary safety devices. Any activated safety devices will
hold the gate open and indicates a problem with the safety device
x
Check the loop detectors. Any activated safety devices can hold the gate
open and indicates a problem with the loop detector or ground loop
Hard Shutdown (2 back
to back obstructions)
LED blinking, Buzzer
sounds for 5 minutes
x
Clear any obstructions from the path of the gate. Press RESET to clear (or
hard reset button)
Gate opens by itself
x
Check accessory inputs and clear them as necessary
15 - APOLLO GATE OPENER TROUBLESHOOTING
TABLE 2
COMPLETE BASIC
Alarm
Active the primary (inherent) reverse system by blocking the gate
with a solid object. The gate should reverse momentarily then stop.
Restart the gate and Lock again with a solid object. The gate should
reverse momentarily, then stop, and go into hard shutdown with an
alarm
●
●
Battery
Check the batteries for any leakage or loose connections. Batteries
should be replaced every two years
●
Fire Dept
Check emergency vehicle access device for proper operation
●
●
Gate Inspect
for
damage
●
Reverse Sys-
tem
Check that the gate reverses on contact with an object in both the
opening and closing cycles
●
●
Loop(s) Check
vehicular
reverse
and
shadow loops for proper operation
●
●
Release
Check manual release for proper operation
●
Complete
Overall Check: Complete check of gate and gate operating system
●
Mounting Hard-
ware
Check screws and nuts
●
14 - MAINTENANCE SCHEDULE - APOLLO GATE OPENER