Burkert Type 6203 - Manual (Page 4)

12
Operating duration
Unless otherwise indicated on the type label, the solenoid
system is suitable for continuous operation.
Important information for functional reliability during
continuous operation!
For long switch-on or switch-off times a minimum
actuation of 1-2 switching operations per day is
recommended.
Service life
High switching frequency and high pressures reduce the
service life.
english 13
6.2. Type label
6203 A 10 EPDM MS
Made in Germany
00229009 W14 LU
230V 50Hz 8W
G3/8 P N0 - 10bar
Type
Operating principle
Orifice
Seal material
Housing material
Identification number
Manufacturer code
Voltage, Frequency, Power
consumption
Connection thread, Nominal pressure
Fig. 1: Location and description of the type label
english
14
7. insTallaTiOn
7.1. safety instructions
Danger!
Risk of injury from high pressure in the equipment!
• Before loosening the lines and valves, turn off the
pressure and vent the lines.
Risk of injury due to electrical shock!
• Before reaching into the system , switch off the power
supply and secure to prevent reactivation!
• Observe applicable accident prevention and safety
regulations for electrical equipment!
Warning!
Risk of injury from improper installation!
• Installation may only be carried out by authorized tech-
nicians with the appropriate tools!
Risk of injury from unintentional activation of the
system and an uncontrolled restart!
• Secure system from unintentional activation.
• Following assembly, ensure a controlled restart.
english 15
7.2. before installation
Installation position:
Installation can be in any position.
Preferably: Drive at the top.
→
Prior to installation check pipelines for dirt and if
required, clean.
Dirt filter: To ensure that the solenoid valve functions
reliably, a dirt filter (≤ 500 μm) must be installed in front of
the valve inlet.
7.3. installation
→
Hold the device with a suitable tool (open-end wrench)
on the housing and screw into the pipeline.
note!
Caution risk of breakage!
• Do not use the coil as a lifting arm.
→
Observe direction of flow:
The arrow on the housing indicates the direction of
flow.
english
Type 6203 EV