Rough Country 376.20 - Manual

02-05 2WD Dodge 1500 6” Suspension Kit
92137600
Kit Contents
9293 Coil springs
1380BOX1 Driver Side Knuckle
1380BOX2 Passengers Side Knuckle
1376BOX3 Front and Rear Cross Members
Sway Bar Links, Sway Bar Brackets
1376Bag1, Front Bump
Stop Brackets, LinkBag2
8117 / 9117 Front Shocks
8112 / 9112 Rear Shocks
6561 3” Block and U-Bolt Kit
OR
6575 4” Block and U-Bolt kit
Tools Needed
13mm Wrench
13mm Socket
14mm Socket
15mm Wrench
15mm Socket
16mm Wrench
18mm Wrench
18mm Socket
19mm Socket
21mm Wrench
21mm Socket
24mm Socket
7/8 Deep Well Socket
T30 Torx Socket
4 Ton Floor Jack
2 Jack Stands
Thank you for choosing Rough Country for your suspension needs.
Rough Country recommends a certified technician installs this system. In addition to these instructions, professional
knowledge of disassemble/reassembly procedures as well as post installation checks must be known. Attempts to install
this system without this knowledge and expertise may jeopardize the integrity and/or operating safety of the vehicle.
Please read all the instructions before beginning the installation. Check the kit hardware against the parts list. Be sure
you have all the needed parts and understand where they go. Also please review the tools needed list and make sure
you have needed tools.
PRODUCT USE INFORMATION
As a general rule, the taller a vehicle is the easier it will roll. We strongly recommend, because of rollover possibility, that
the vehicle be equipped with a functional roll-bar and cage system. Seat belts and shoulder harnesses should be worn
at all times. Avoid situations where a side rollover may occur.
Braking performance and capabilities are decreased when significantly larger/heaver tires and wheels are used. Take
this into consideration while driving. Also, speedometer recalibration is necessary when larger tires are installed.
Do not add, alter, or fabricate any factory or after-market parts which increase vehicle height over the intended height of
the Rough Country product purchased. Mixing component brands, lifts, and/or combining body lift with suspension lifts
voids all warranties. Rough Country makes no claims regarding lifting devices and excludes any and all implied claims.
We will not be responsible for any product that is altered.
This kit is packaged as a leveling kit—raising the front 6” and the back 3”. If you desire a different look or if your truck
has a tool box or something else that is going to bring the rear end down, please consult with your sales representative
about the option of a 4” block and u-bolt kit part # 6575, or the use of an add-a-leaf.
This 6” suspension system was developed for 315/70/17 tire on an after market wheel with 4.5” of back spacing.
NOTICE TO DEALER AND VECHICLE OWNER
Any vehicle equipped with any Rough country product must have the “Warning to Driver” decal installed on the sun visor
or dash. The decal is to act as a constant reminder for whoever is operating the vehicle of its unique handling character-
istics. INSTALLING DEALER—It is your responsibility to install the warning decal and to forward these installation in-
structions on too the vehicle owner for review and to be kept in the vehicle for its service life.
Torque Specs
Size Grade 5 Grade 8
5/16” 15 ft/lbs 20 ft/lbs
3/8” 30 ft/lbs 35 ft/lbs
7/16” 45 ft/lbs 60 ft/lbs
1/2” 65 ft/lbs 90 ft/lbs
9/16” 95 ft/lbs 130 ft/lbs
5/8” 135 ft/lbs 175 ft/lbs
3/4” 185 ft/lbs 280 ft/lbs