beautypg.com

Notice to installer, General hazards – Guardian Technologies QUIETPACT 40LP 004701-0 User Manual

Page 18

background image

notIce to Installer

These Installation Instructions have been published

by the manufacturer to aid in the installation of the

products described in this manual. The manufac-

turer assumes that installation personnel are familiar

with the procedures for installing such products, or

similar products. The manufacturer also assumes

that personnel have been trained in the recommend-

ed installation procedures for these products and

that such training includes (a) use of common hand

tools, (b) use of special tools, and (c) use of any tools

and/or equipment from other suppliers.
The manufacturer cannot anticipate every possible

circumstance that might involve a hazard. The warn-

ings in this manual, and on tags and decals affixed

to the unit, are, therefore, not all inclusive. If using

a procedure, work method or operating technique

the manufacturer does not specifically recommend,

ensure that it is safe for others. Also make sure the

procedure, work method or operating technique uti-

lized does not render the generator unsafe.
Information, illustrations, specifications, etc., con-

tained in these Installation Instructions are based on

the latest information available at the time of publica-

tion. Every effort has been expended to be sure that

such data is both accurate and current. However, the

manufacturer reserves the right to change, alter or

otherwise improve this product at any time without

prior notice.

danger

Despite the safe design of this generator,

operating this equipment imprudently, neglecting

its maintenance or being careless can cause

possible injury or death. Permit only responsible

and capable persons to operate or maintain this

equipment.

Potentially lethal voltages are generated by

these machines. Ensure all steps are taken to

render the machine safe before attempting to

work on the generator.

Parts of the generator are rotating and/or hot

during operation. Exercise care near running

generators.

general hazards

• For safety reasons, the manufacturer recommends

that the installation, initial start-up and main-

tenance of this equipment is carried out by an

Authorized Service Dealer.

• The engine exhaust fumes contain carbon monox-

ide, which can be DEADLY. This dangerous gas, if

breathed in sufficient concentrations, can cause

unconsciousness or even death. This exhaust

system must be installed properly, in strict com-

pliance with applicable codes and standards.

Following installation, do nothing that might ren-

der the system unsafe or in noncompliance with

such codes and standards. The generator com-

partment must be completely vapor sealed from

the vehicle interior. There must be no possibility of

exhaust fumes entering the vehicle interior. Never

operate this equipment with a leaking or defective

exhaust system.

• Keep hands, feet, clothing, etc., away from drive

belts, fans, and other moving or hot parts. Never

remove any drive belt or fan guard while the unit

is operating.

• Adequate, unobstructed flow of cooling and ven-

tilating air is critical to correct generator opera-

tion and is required to expel toxic fumes and fuel

vapors from the generator compartment. Without

sufficient cooling airflow, the engine/generator

quickly overheats, which causes serious damage

to the generator. Do not alter the installation or

permit even partial blockage of ventilation provi-

sions, as this can seriously affect safe operation of

the generator.

• When working on this equipment, remain alert

at all times. Never work on the equipment when

physically or mentally fatigued.

• Before performing any maintenance on the gen-

erator, disconnect its battery cables to prevent

accidental start up. Disconnect the cable from the

battery post indicated by a NEGATIVE, NEG or (–)

first. Reconnect that cable last.

• Never use the generator or any of its parts as a

step. Stepping on the unit can stress and break

parts, and may result in dangerous operating con-

ditions from leaking exhaust gases, fuel leakage,

oil leakage, etc.

• Never insert any tool or other object through open-

ings in the generator interior, even if the unit is not

running. Serious injury or damage to the equip-

ment may occur.

safety rules

recreational vehicle generator

DanGer: For fire safety, installation of a generator into a recreational vehicle must comply

strictly with article 551, nFPa 70; anSI c1-1975; anD, anSI a119.2-1975/nFPa 501c “Standard

for recreational vehicles” (Part 3, “Installation of electrical Systems”). In addition, installation

must comply with the manufacturer’s instructions and recommendations.