Bolens TMO-3394704 - Manual (Page 6)

IV. SERVICE
1. Use extra care in handling gasoline and other fuels. They are
flammable and vapors are explosive.
a. Use only an approved container.
b. Never remove gas cap or add fuel \with the engine running.
Allow engine to cool at least two minutes before refueling.
Do not smoke.
c. Never refuel the machine indoors.
d. Never store the machine or fuel container inside where
there is an open flame, or spark, such as a water heater,
space heater, clothes dryer and the like.
2. Never run a machine inside a closed area.
3. Check ^ equently and keep nuts and bolts, especially blade
attachment bolts, tight and keep equipment in safe working
condition.
4. Never tamper with safety devices. Check their proper operation
regularly. Use all guards as instructed in this manual.
5. To reduce fire hazard, keep machine free of grass, leaves or
6 .
9.
10 .
1 1 .
12 .
other debris build-up. Clean up oil or fuel spillage. Allow
machine to cool before storing.
Stop and inspect the equipment for damage if you strike an
object. Repair, if necessary, before re-starting and operating
the machine.
Never make adjustments or repairs with the engine running.
Grass catcher components are subject to wear, damage and
deteriorate, which could expose moving parts or allow objects
to be thrown. Frequently, check components and replace with
manufacturer’s recommended parts when necessary.
Mower blades are sharp and can cut. Wrap the blade(s) or
wear gloves and use extra caution when servicing blade(s).
Check brake operation frequently. Adjust and service as
required.
Muffier, engine, and belt guards become hot during operation
and can cause a burn. Allow to cool down before touching.
Do not change the engine governor settings or overspeed the
engine.
Your unit was built to be operated according to the rules for safe ope tion in this manual. As with any type
DANGER: of power equipment, carelessness or error on the part of the operator can result in serious injury. If you vio­
late any of these rules, you may cause serious injury to yourself or n'hers.
ASSEMBLY INSTRUCTIONS
IMPORTANT: After assembly, service engine with
gasoline, and check oil level as instructed in the
engine section of this manual.
NOTE: Reference to right or left hand side of the
unit is observed from the driver’s seat, facing for­
ward.
UNPACKING
1. Remove the lawn tractor from the carton as fol-
lovi/s. Open the top flaps. Remove all loose parts
and carton inserts. Cut the front corners.of the
carton. Make certain brake is released, and push
the unit out of the carton.
2. Remove page four from this manual and lay the
contents of the hardware pack on the illustration
for identification.
Screwdriver
BAHERY INF0Rr'" ATI0N
WARNING
A
A. Battery acid must be handled with great care as
contact with it can burn and blister the skin. It is
also advisable to wear protective clothing (goggles,
rubber gloves and apron) when working with it.*
B. Should battery acid accidentally splatter into the
eyes or onto the face, rinse the affected area
immediately with clean cold water. If there is any
further discomfort, seek prompt medical attention.
C. If acid spills on clothing, first dilute it with clean
water, then neutralize with a solution of ammonia/
water or baking soda/water.
D. Since battery acid is corrosive, do not pour it into
any sink or drain. Before discarding empty elec­
trolyte containers, rinse them with a neutralizing
solution.
E. NEVER connect or disconnect charger clips to bat­
tery while charger is turned on as it can cause
sparks.
F. Keep all lighted materials (cigarettes, matches,
lighters) away from the battery as the hydrogen gas
generated during charging can be combustible.
G. As a further precaution, only charge the battery in
d well-ventiiated area.
*Always shield eyes, protect skin and clothing
when working near batteries.
ACTIVATING THE BAHERT
Do not activate battery (fill with battery acid) until
battery is actually placed in service. Be certain to
read previous warnings before activating ifie h-L-
tery.
1. Open the battery box (located under the seat) by
pressing in on the end (right hand side) and lifting
up. Remove the batteiV. The clear plastic drain
lube should be attached to the battery.
Open the battery pack. Be careful riot to puncture
the box. It contains the battery fluid (acid) in a
plastic container and one short plastic tube.
2
.