Cub Cadet ZD - Manual (Page 10)

EZT ® 7
Vehicle tires improperly inflated Refer to vehicle manufacturer suggested pressure
Control linkage bent or out of adjustment Repair or replace linkage, Pages 8 and 11
Bypass assembly sticking Repair or replace bypass, Page 21
warning
do not attempt any servicing or ad-
justments with the engine running.
use extreme caution while inspecting
the drive belt assembly and all vehicle
linkage!
follow all safety procedures outlined in
the vehicle owner’s manual.
sEcTion 3. TrouBlEsHooTing
In many cases, problems with the EZT ® are not
related to a defective transaxle, but are caused
by slipping drive belts, partially engaged bypass
valves, and loose or damaged control linkages.
Be sure to perform all operational checks and
adjustments outlined in Section 4, Service
and Maintenance, before assuming the pump
is malfunctioning. Table 3 below provides a
troubleshooting checklist to help determine the
cause of operational problems.
Table 3. EZT Troubleshooting checklist
possible cause corrective action
uniT opEraTEs in onE dirEcTion onlY
uniT is noisY
uniT Has no/low powEr
TransaXlE lEaKs oil
Control linkage bent or out of adjustment Repair or replace linkage, Page 8
Drive belt slipping or pulley damaged Repair or replace drive belt or pulley, Page 8
Oil level low or contaminated oil Fill to proper level or change oil, Page 9
Excessive loading Reduce vehicle loading, Page 8
Loose parts Repair or replace loose parts
Bypass assembly sticking Repair or replace linkage
Air trapped in hydraulic system Purge hydraulic system, Page 10
Engine speed low Adjust to correct setting
Control linkage bent or out of adjustment Repair or replace linkage, Page 8
Drive belt slipping or pulley damaged Repair or replace drive belt or pulley, Page 8
Oil level low or contaminated oil Fill to proper level or change oil, Page 9
Excessive loading Reduce vehicle loading, Page 8
Bypass assembly sticking Repair or replace linkage
Air trapped in hydraulic system Purge hydraulic system, Page 10
Debris buildup around transaxle Clean off debris, Pages 2 and 8
Cooling fan damaged Repair or replace cooling fan
Oil level low or contaminated oil Fill to proper level or change oil, Page 9
Excessive loading Reduce vehicle loading, Page 8
Air trapped in hydraulic system Purge hydraulic system, Page 10
Damaged seals, housing, or gaskets Replace damaged component
Air trapped in hydraulic system Purge hydraulic system, Page 10
vEHiclE doEs noT drivE/TracK sTraigHT
uniT is opEraTing HoT