A.J. Antunes & Co VCT-20 9200552 - Manual (Page 31)

31
VERTICAL CONTACT TOASTER
P/N 1010719 Rev. E 02/13
1 0011264 Conveyor Belt 2
0800204 1/2" Pitch Link, Small 4
0800121 3/4" Pitch Link, Large 37
2 2150117 Idler Shaft 2
3 0011329 Conveyor Cover Assy. 2
4 0010475 Tensioner Assy. (Incl. #40, 76, 85) 4
5 0800332 Rod, Conveyor Cover 4
6 2150190 Sprocket 8
7 7000199* Spacer Kit 2
8 0503362 Control Cover 1
9 2150118 Drive Shaft 2
10 0700452 Power Cord/Plug, NEMA 6-20P (Std.) 1
0700588 Power Cord/Plug, HRN/IEC-309 1
11 7000198 Control Board 1
12 2150158 Ball Bearing 2
13 2150186 Bearing 6
14 0503459 Bearing Retainer/Spacer 6
15 0503376 Bearing Retainer 6
16 7000167 Bearing & Retainer Kit 1
(Includes #13,14,15 & 59)
17 2150181 Drive Sprocket 2
18 2150187 Drive Chain 1
19 0011299 Idler Sprocket & Bearing 1
20 0501232 Bracket, Idler Sprocket 1
21 0503589 Bracket, Motor Mounting 1
22 7000175 Drive Motor Kit, 60 Hz (Incl. #58) 1
7000240 Drive Motor Kit, Dual Frequency
50/60 Hz (Incl. #58) 1
23 2150173 Sprocket w/Setscrew, Motor 1
24 4010137 Rocker Switch, On/Off (250 VAC) 1
25 4060355 Terminal Block 1
26 405K125 Relay, Solid State 2
27 4010187 Transformer 1
28 7000192 Conveyor Belt Wrap (Pack of 2) 1
29 7000186 Roller Tensioner Assy. (Pack of 2) 1
30 0503496 Tensioner Bracket, Right 2
31 0503497 Tensioner Bracket, Left 2
32 1001037 Label, Control 1
33 10P1047* Label, Dial (Pack of 10) 1
34 2100253 Knob, Control 2
35 0503390 Cover, End Housing 1
36 4050214 Thermocouple Assy. 1
37 0021170 Weldment, End Housing 1
38 7000110 Release Sheet (Pack of 3) -
7000111 Release Sheet (Pack of 10) -
39 0021169 Control Housing 1
40 7000121 Slide Rail Kit (Includes 2
slide rails for tensioners) 2
41 0021207 Conveyor Cam 2
42 7000176 Thermocouple Retainer Kit 2
43 4030332 High Limit Thermostat 1
44 040K251 Strain Relief 1
0400315 Strain Relief (9200552 only) 1
45 0400138 Locknut, 1/2" 1
46 0503590 Bracket, Motor 1
47 0700580 Wire Set (not shown) 1
48 0503385 Bun Chute 1
48A 0503677 Bun Chute (9200650 Only) 1
49 4030333 Auxiliary Heater, Air, 400 Watts 2
50 7000165 Auxiliary Thermocouple Kit 1
51 7000200 Platen (208 VOLT) 1
52 2100252 Tape 4
53 0503359 Bracket, Relay 1
54 0503150 Heater Clip 2
55 303P125* Hinge Pin, Belt Wrap 2
56 0400312 Damper 2
57 0503533 Bracket, Auxiliary Thermocouple 1
58 4000165 Fan Blade, Motor 1
59 2100256 Tape 8
60 0011301 Damper Support Assy. 2
61 0502199 Spacer 4
62 0500464 Retainer, Bearing 1
63 0011321 Damper Assy. 1
64 0011330 Heat Shield Assy. 1
65 325P163* Setscrew, 1/4-28 x 5/16" 8
66 100P864* Label, Caution Hot 1
67 308P115* Screw, #8-32 x 3/8" (10 mm) 2
68 304P105* Nut, #4-40, "KEPS" 4
69 406P107* Cable Tie 1
70 308P143* Nut, #8-32, "KEPS" 6
71 310P154* Screw, #10-32 x 3/8" 4
72 310P140* Washer, #10 6
73 308P101* Nut, #8-32 3
74 306P101* Nut, Hex, #6-32 2
75 306P123* Screw, #6-32 x 7/8" 2
76 308P145* Nut, Hex Acorn, #8-32 14
77 100P900* Label, Service 1
78 325P104* Washer, 1/4" 4
79 325P109* Screw, 1/4-20 x 1/2" 4
80 308P124* Screw, 1-Way, #8-32 x 1/2" 1
81 10P1022* Label, Heaters 1
82 310P136* Screw, #10-32 x 1-1/4" 4
82A 310P180* Screw, #10-32 x 1-3/4
(9200650 Only) 1
83 308P133* Screw, #8-32 x 1/4" 1
84 308P151* Screw, SEMS, #8-32 x 5/16" 4
85 308P181* Screw, Flat Hd., #8-32 x 3/8" 4
86 218P145* Cover, Leg, Bumper 4
87 331P103* Shoulder Bolt, 5/16-18 x l" 1
88 306P105* Screw, #6-32 x 1/2" 1
89 331P106* Lockwasher, 5/16" 1
90 212P118* Flat Washer, 5/16" 1
91 331P101* Nut, Hex, 5/16 x 18" 1
92 300P102* Nut, Tinnerman 2
93 210P230 Bumper, Recess Leg, 1" 4
94 0600132 Spring, Damper Support 4
95 4010107 Interlock Switch 1
96 306P104* Screw, #6-32 x 1/4" 8
97 0503495 Retainer, Tensioner Bracket, RH 1
98 0503507 Retainer, Tensioner Bracket, LH 1
99 2120147 Spacer, Leg (9200650 Only) 4
100 1001056 Label, Crown and Heel
(9200650 Only) 1
101 2100259 Slide Bar 4
102 0503455 Tension Spring, Inner 4
* Only available in packages of 10.
Item Part No. Description Qty. Item Part No. Description Qty.