SaltDogg SCH096 Series Self-Contained Hopper Spreader - Manual (Page 2)

Quality since 1946
9049 Tyler Blvd. • Mentor, Ohio 44060
Phone (440) 974-8888 • Fax (440) 974-0165
Toll-Free Fax 800-841-8003 • buyersproducts.com
2
Quality since 1946
Engine and Gearbox Oil:
The engine crankcase is filled with 1 quart of SAE 5W-30
motor oil at the factory. The gearbox is filled with SAE 90
gear lubricant at the factory.
Warning! Verify that the above oil viscosity meets your
operating requirements. If not, empty and refill with the
proper viscosity. Before starting spreader, check that the
engine crankcase and gearbox are filled to the proper
level with lubricant.
SAFETY PRECAUTIONS
Warning! Observe the following Safety Precautions
before, during and after operating this spreader. By fol-
lowing these precautions and common sense, possible
injury to persons and potential damage to this machine
may be avoided.
1. Read this entire Owners Manual before operating this
spreader. This includes the Tecumseh Formula XL/C 10 hp.
engine Operator’s Manuals.
2. Read all safety decals on the spreader before operat-
ing.
3. Check to make sure all safety guards are securely
mounted into place before operating this spreader.
4. Make sure the engine cover is securely fastened to the
spreader before operating the spreader.
5. Verify that all personnel are clear of the spreader spray
area before starting or operating this spreader.
6. Keep all loose clothing, hair, jewelry and limbs clear of
the spreader before starting or operating this spreader.
7. Do not over-load your vehicle beyond payload limits. If
there are any questions, contact the vehicle manufacturer.
8. Do not adjust, clean, oil or unclog material jambs with-
out first turning off the spreader, removing the engine
spark plug connector.
9. Do not climb on or in the spreader during operation.
Do not ride on the spreader while the vehicle is in motion.
10. Make sure the spreader is securely fastened to the
vehicle in accordance with this manual.
11 . Do not operate a spreader that is in need of mainte-
nance or repairs.
12. Never lay tools or equipment on top of the 12 VDC
spreader’s battery. This could accidentally ground the pos-
itive (+) battery terminal, resulting in electrical shock,
burns or damage to the vehicle or equipment.
13. Avoid contact with battery acid. Battery acid can seri-
ously burn eyes or skin. Battery acid can also burn holes in
clothing.
14. Always disconnect the battery before removing or
replacing electrical components.
15. A charging battery gives off gases that can explode if
touched by a spark or flame. Cover the top of the battery
with electrically non-conductive material to keep sparks
away from battery gases.
16. If the spreader must be operated with the spreader
battery disconnected, insulate the positive (red) battery
cable and red wire from the engine alternator with electri-
cal tape.
17. Do not use side extensions on the T304 Stainless Steel
spreader to increase salt storage capability. Using side
extensions may damage hopper and cause injury to person-
nel.
SCH096 SPREADER WARRANTY
INFORMATION
T his warranty replaces all previous warranties and no
employee of this company is authorized to extend additional
warranties, or agreements, or implications not explicitly
covered herein.
Buyers Products Company warrants all parts of the product
to be free from defects in material and workmanship for a
period of one (1) year, excluding the Tecumseh gasoline
engine, from the date of installation. Parts must be properly
installed and used under normal conditions. Normal wear is
excluded.
Any part which has been altered, including modifications,
misuse, accident, or lack of maintenance will not be consid-
ered under this warranty.