SaltDogg 1400701SS Self-Contained Stainless Steel Hopper Spreaders - Manual

1
TM
Owners Manual
1400601SS, 1400701SS Self-Contained Stainless Steel Hopper Spreaders
CAUTION
Do not overload vehicle beyond the vehicle’s Gross
Vehicle Weight Rating (GVWR) or Gross Axle
Weight Ratings (GAWR). Check the vehicle’s load
rating certification sticker for maximum vehicle
capacity.
General Information
1. Recommended Vehicle Requirements:
• 3/4 or 1 ton Pick-up Truck Above 8500# GVWR
SPREADER WARRANTY INFORMATION
This warranty replaces all previous warranties and no employee
of this company is authorized to extend additional warranties, or
agreements, or implications not explicitly covered herein.
Buyers Products Company warrants all parts of the product to be
free from defects in material and workmanship for a period of one (1)
year, from the date of installation. Parts must be properly installed
and used under normal conditions. Normal wear is excluded.
Any part which has been altered, including modifications, misuse,
accident, or lack of maintenance will not be considered under this
warranty.
The sole responsibility of Buyers Products Company under this
warranty is limited to repairing or replacing any part(s) which
are returned, prepaid, 30 days after such defect is discovered,
and returned part(s) are found to be defective by Buyers Products
Company.
Authorization from Buyers Products Company must be obtained
before returning any part. The following information must accom-
pany defective parts returned to Buyers Products Company: RMA#,
spreader model, serial number, date installed, and distributor from
whom purchased.
Buyers Products Company shall not be liable for damage arising out
of failure of any unit to operate properly, or failure, or delay in work,
or for any consequential damages. No charges for transportation or
labor performed on any part will be allowed under this warranty.
9049 Tyler Blvd. • Mentor, Ohio 44060
Phone (440) 974-8888 • Fax (440) 974-0165
www.saltdogg.com
2. Average Material Weights:
Note: To calculate the total spreader weight (including ice
control material); add the empty spreader weight plus the
ice control material and spreader accessories.
MATERIAL WEIGHT (POUNDS PER CUBIC YARD)
#1 Rock Salt 950
#2 Rock Salt 1,215
Coarse Sand - Dry 2,565
Coarse Sand - Wet 3,240
Table of Contents
Warranty Information ................................................................ 1
General Information ............................................................... 1-2
Safety Precautions ..................................................................... 2
Installation Instructions ........................................................2-4
Spreader Operation .................................................................... 5
Spreader Maintenance .............................................................. 5
Repair Parts & Drawings .......................................................6-8