TurboChef Technologies Residential Single and Double Wall Oven - Manual (Page 116)

A.24 APPENDIX - REPLACING OVEN COMPONENTS
Item Description Item Part # Hardware Description Hardware Part Number(s)
Blower Motor Controller 100446 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x4)
Blower Motor, Lower RWD-9042 Nut, 1/4-20, Serrated Hex Flange, Plated Steel 100906 (x4)
Blower Motor, Upper RWD-9040 Nut, 1/4-20, Serrated Hex Flange, Plated Steel 100906 (x4)
Catalytic Converter RWD-9066 None None
Cover, Blower Motors RWD-9280 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x4)
Cover, Door Switch RWD-9359 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x2)
Cover, Hinge Pocket RWD-9472 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x2)
Cover, Motor End RWD-9282 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x4)
Cover, Waveguide RWD-9164 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x2)
Diverter RWD-9283 None None
Door Receiver 104123 Screw, 10-32 x 1/4 LG, PFLH 100 DEG, SS 101402 (x2)
Door Switch, LHS RWD-9187 Screw, #6-32 x 1/2 LG, PPH, SS 101570 (x3)
Door Switch, RHS RWD-9186 Screw, #6-32 x 1/2 LG, PPH, SS 101570 (x3)
Heater, Upper Oven (208V) RWD-9394 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x8)
Heater, Upper Oven (240V) RWD-9065 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x8)
Hinge Pocket, LHS RWD-9098 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x3)
Hinge Pocket, RHS RWD-9097 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x3)
Jetplate, Lower RWD-9576 None None
Jetplate, Upper RWD-3017
Holder, Jet Plate
Screw, SH MTL, #8 x 1/2 Serrated PHTRH RWD-9404 (x2)
101688 (x4)
Lamp, Halogen, Upper Oven RWD-3014 None None
Microwave Stirrer Assembly RWD-9275
Washer, Lock, #10 EXT TH, CRES
Screw, #10-32 x 1/2, HEX, SERR FLG HD, SS 102260
104138
Rack RWD-9167 None None
RTD RWD-9364 Screw, SH MTL, #8 x 1/2 Serrated PHTRH 101688 (x2)
Stirrer Shaft RWD-9070 None None
Stirrer, Coupling Hub 104133 None None
Stirrer, Coupling Spider Insert 104134 None None
Stirrer, Shaft Support RWD-9077 Screw, #8-32 x 5/8 LG, SEMS, PPHD, SS 102962 (x4)
Stirrer, Stud Plate RWD-9072 None None
Support Rack, LHS RWD-9165 None None
Support Rack, RHS RWD-9166 None None
Thermostat, 270F, Open on Rise 104228 Screw, #6 x 1/2, PPHD, DRL-PT, SS 101687 (x2)
Speedcook Oven Cavity Component Detail, DWO Gen 1, DWO Gen 2,
and SWO
DANGER: Before removing or replacing any oven component, ensure the oven is removed from any
power source (i.e., the breaker is turned off ). Failure to do so can result in serious injury or death.
WARNING: Before removing or replacing any oven component, thoroughly read the safety instructions
found at the front of this manual and in Oven Systems (Section 5) and Troubleshooting (Section 6). Adhere to
all precautions and warnings outlined in these sections, as failure to do so could result in serious injury or death.
CAUTION: Before removing/installing any component, make sure it is disconnected from the wire
harness (where applicable).