Generac Power Systems 0940-1 - Manual (Page 18)

INSTALLATION SAFETY RULES
DANGER: FOR FIRE SAFETY, INSTALLATION OF A GENERATOR INTO A RECREATIONAL
VEHICLE MUST COMPLY STRICTLY WITH ARTICLE 551, NFPA 70; ANSI C1-1975; AND,
ANSI All9.2-1975/NFPA 501C “STANDARD FOR RECREATIONAL VEHICLES" (PART 3,
“INSTALLATION OF ELECTRICAL SYSTEMS"). IN ADDITION, THE MANUFACTURER'S
INSTRUCTIONS AND RECOMMENDA TIONS MUST BE COMPLIED WITH.
NOTICE TO INSTALLER
The Installation Instructions have been published by
Generac Corporation to aid in the installation of the
products described in this manual. Generac assumes
that installation personnel are familiar w/ith the proce­
dures for installing such products, or similar products
that Generac manufactures. Generac also assumes
that personnel have been trained in the recommended
installation procedures for these products and that
such training includes (a) use of common hand tools,
(b) use of special Generac tools, and (c) use of any
tools and/or equipment from other suppliers.
We could not possibly know of and advise the recre­
ational vehicle trade of all conceivable methods, proce­
dures or techniques by which to perform an installa­
tion. We could not know of the possible hazards that
might result from each installation method, procedure
or technique. We have not undertaken any such wide
evaluation. Therefore, people who use a method, pro­
cedure or technique that Generac does not specifically
recommend must first completely satisfy themselves
that their safety, the safety of the vehicle's occupants
and the product's safety is not endangered by the
method, procedure or technique selected.
Information, illustrations, specifications, etc., contained
in this Installation Manual are based on the latest infor­
mation available at the time of publication. Every effort
has been expended to be sure that such data is both
accurate
and current. However, the manufacturer
reserves the right to change, alter or otherwise
improve this product at any time without prior notice.
SAFETY RULES
A Gasoline is extremely FLAMMABLE and its vapors
^ are EXPLOSIVE. Do not permit smoking, open
flame, sparks or any source of heat in the vicinity
while handling gasoline. Comply with all laws gov­
erning the storage and handling of gasoline.
Fuel lines must be properly installed, properly fas­
tened and free of leaks. There must be no possi­
bility of gasoline vapors entering vehicle interior.
• You are required to install an approved, flexible,
non-conductive fuel line between the generator
fuel connection point and rigid fuel lines.
A If the generator can be equipped with a liquid
propane (LP) gas fuel system, install the unit so it
complies with all codes, standards and regulations
pertaining to such systems. LP gas is highly explo­
sive. The gas tends to settle in low areas where
even the slightest spark can ignite it and cause an
explosion. Do not allow gas vapors to enter the
vehicle.
• Engine exhaust gases contain DEADLY carbon
monoxide gas. This dangerous gas, if breathed in
sufficient concentrations, can cause unconscious­
ness or even death. Install the exhaust system in
strict compliance with applicable codes, standards
and regulations. There must be no possibility for
exhaust gases entering the vehicle interior and
endangering people or animals.
A The generator set produces dangerously high
^ electrical voltage. Contact with bare wires, bare
terminals, etc., will result in extremely hazardous
and possibly lethal electrical shock.
• All applicable electrical codes, standards and reg­
ulations must be strictly complied with in the instal­
lation and use of this equipment.
• The generator must be properly grounded (bond­
ed) to the vehicle chassis or frame.
A If the vehicle electrical circuits can be powered by
any other source of electricity (such as a “dockside'’
power receptacle), there must be no possibility of
connecting the different power sources to the vehi­
cle circuits at the same time. The “dockside” (utility)
power source must be positively isolated from the
vehicle circuits whenever the generator is operat­
ing. Failure to isolate the vehicle circuits from the
dockside power supply when the generator is run­
ning may result in damage to the generator or seri­
ous injury or death to dockside (utility) power work­
ers due to backfeed of electrical energy.
• Never work on the equipment while standing in
water, while barefoot, or while hands or feet are
wet. Dangerous electrical shock will result.
• Jewelry conducts electricity, which can cause dan­
gerous electrical shock. Remove all jewelry (such
as rings, watches, or bracelets) before working on
this equipment.
• The generator requires an adequate flow of air for
cooling and ventilation. Without sufficient cooling
air flow, the engine-generator quickly overheats,
which causes serious damage to the generator, a
fire or an explosion. Generator air inlet and outlet
openings must be provided in strict compliance
with the manufacturer's recommendations.
• Never work on this equipment while physically or
mentally fatigued. Stay alert at all times.
A Storage batteries give off EXPLOSIVE hydrogen
^ gas while charging. The battery used for cranking
and starting this generator should be installed in
its own vented compartment. Provide adequate
ventilation for the battery, to prevent explosive
hydrogen gas from accumulating.
• Never insert any tool or other object through open­
ings in the generator interior, even if the unit is not
running. You might seriously injure yourself or
damage the equipment.
• Staying alert and using “common sense” are major
measures for preventing accidents.
1 6 —