Rockwell Automation Flex/WebPak 3000 Digital DC Drive Blower Motor Starter Kit - Manual

Reliance, FlexPak and WebPak are trademarks of Rockwell Automation.
© 2000 Rockwell International Corporation
Blower Motor Starter Kit
for FlexPak 3000 and WebPak 3000 Digital DC Drives
Model Number 902FKxxxx
Instruction Manual D2-3295-4
Product Description
This instruction manual describes the installation procedure for the blower motor starter kit used with
FlexPak
™ 3000 and WebPak ™ 3000 drives. The kit includes a fused three-phase motor starter with an
adjustable overload and interlock, wire harness, and in-line fuses.
Verifying That the Kit Rating Matches the Blower Motor
Before installation, make sure the kit you are installing is rated for the blower motor being connected. Also
make sure that the blower motor rated voltage matches the drive AC line voltage. See table 1 for ratings and kit
model numbers.
!
ATTENTION: Only qualified personnel familiar with the construction and operation of this
equipment and the hazards involved should install, adjust, operate and/or service this equipment.
Read and understand this manual in its entirety before proceeding. Failure to observe this
precaution could result in severe bodily injury or loss of life.
ATTENTION: All interconnecting wiring must be sized and installed in conformance with
applicable local, national, and international codes. Failure to observe this precaution could result
in damage to, or destruction of, the equipment.
Table 1 – Blower Motor Starter Kit Model Numbers 1
1.
Model numbers apply to 1.5 HP through 150 HP @ 230 VAC and 3 HP through 600 HP @ 460 VAC.
Blower Motor Starter Full Load Amp Range Model Number
0.4 - 0.63 Amps 902FK0101
0.63 - 1.0 Amps 902FK0201
1.0 - 1.4 Amps 902FK0301
1.4 - 1.8 Amps 902FK0401
1.7 - 2.4 Amps 902FK0501
2.2 - 3.1 Amps 902FK0601
2.8 - 4.0 Amps 902FK0701
3.5 - 5.0 Amps 902FK0801
4.5 - 6.5 Amps 902FK0901
6.0 - 8.5 Amps 902FK0111
7.5 - 11.0 Amps 902FK0121
Trademarks not belonging to Rockwell Automation are property of their
respective companies.