Wagner ProCoat - Manual (Page 3)

3 English
HAZARD: GeneRAL
Can cause severe injury or property damage.
PReVentIon:
• Read all instructions and safety precautions before
operating equipment.
• Follow all appropriate local, state, and national
codes governing ventilation, fire prevention, and
operation.
• The United States Government Safety Standards
have been adopted under the Occupational
Safety and Health Act (OSHA). These standards,
particularly part 1910 of the General Standards and
part 1926 of the Construction Standards should be
consulted.
• Use only manufacturer authorized parts. User
assumes all risks and liabilities when using parts
that do not meet the minimum specifications and
safety requirements of the pump manufacturer.
• Before each use, check all hoses for cuts, leaks,
abrasion or bulging of cover. Check for damage or
movement of couplings. Immediately replace the
hose if any of these conditions exist. Never repair a
paint hose. Replace it with another grounded high-
pressure hose.
• All hoses and fittings must be secured before
operating spray pump. Unsecured parts can eject
at great force or leak a high pressure fluid stream
causing severe injury.
• All hoses, swivels, guns, and accessories must be
pressure rated at or above 2800 PSI/193 BAR.
• Do not spray outdoors on windy days.
• Wear clothing to keep paint off skin and hair.
• Do not operate or spray near children. Keep
children away from the equipment at all times.
• Do not overreach or stand on an unstable support.
Keep effective footing and balance at all times.
• Stay alert and watch what you are doing.
• Do not operate the unit when fatigued or under the
influence of drugs or alcohol.
Important Electrical Information
IMPoRtAnt: Use only a 3-wire extension cord that
has a 3-blade grounding plug and a 3-slot receptacle
that will accept the plug on the product. Make sure
your extension cord is in good condition. When
using an extension cord, be sure to use one heavy
enough to carry the current your product will draw.
An undersized cord will cause a drop in line voltage
resulting in loss of power and overheating. A 14
or 12 gauge cord is recommended (see chart). If
an extension cord is to be used outdoors, it must
be marked with the suffix W-A after the cord type
designation. For example, a designation of SJTW-A
would indicate that the cord would be appropriate
for outdoor use.
Wagner Spray Tech accessory extension cords
recommended:
P/N 0090241 - 20 foot extension cord.
P/N 0090242 - 35 foot extension cord.
Cord gauge Maximum cord length
12 150 feet
14 100 feet
Do not use more than 50 feet of spray hose. If you
need to spray further than 50 feet from your power
source, use more extension cord, not more spray
hose.
Grounding Instructions
This product must be grounded. In the event of an
electrical short circuit, grounding reduces the risk of
electric shock by providing an escape wire for the
electric current. This product is equipped with a cord
having a grounding wire with an appropriate grounding
plug. The plug must be plugged into an outlet that is
properly installed and grounded in accordance with all
local codes and ordinances.
WArNINg - Improper installation of the
grounding plug can result in a risk of electric
shock.
If repair or replacement of the cord or plug is necessary,
do not connect the green grounding wire to either
flat blade terminal. The wire with insulation having a
green outer surface with or without yellow stripes is the
grounding wire and must be connected to the grounding
pin.
Check with a qualified electrician or serviceman if the
grounding instructions are not completely understood, or
if you are in doubt as to whether the product is properly
grounded. Do not modify the plug provided. If the plug
will not fit the outlet, have the proper outlet installed by a
qualified electrician.
This product is for use on a nominal 120 volt circuit and
has a grounding plug that looks like the plug illustrated
below. Make sure that the product is connected to an
outlet having the same configuration as the plug. No
adapter should be used with this product.
Grounded Outlet
Grounding Pin
Cover for grounded outlet box
If you experience problems with your sprayer at
any time during assembly, operation, or cleanup,
please refer to the troubleshooting section of this
manual (page 22), or call customer service at:
1-800-328-8251