Montigo C42DV - Manual (Page 2)

Page 2
C42-DV Gas Fireplace
®
Part No. XG0119C
Introduction
Thank You for choosing a Montigo C-Series Fireplace.
About the C42 Fireplace:
The includes a 27,000 BTU dual burner with embers and a five piece
ceramic logset. This model is available in four versions.
C42DT - Top Vent, Millivolt Pilot
C42DR - Rear Vent, Millivolt Pilot
C42DT-I - Top Vent, Intermittent Pilot (HSI)
C42DR-I - Rear Vent, Intermittent Pilot (HSI)
The C42-DV is rated for Natural Gas at 27,000 BTU/H (7.33 Kilowatts)
Input or Propane at 27,000 BTU/H (7.33 Kilowatts) Input.
How to use this manual:
This manual covers all models and unless otherwise specified, the
designation C42-DV refers to all models. Sections which are
specific to a particular model are marked with a
symbol,
plus the appropriate model number.
Warranty and Installation Information:
The Montigo warranty will be voided by, and Montigo disclaims
any responsibility for, the following actions:
n Modification of the fireplace and/or components including
Direct-Vent assembly or glass doors.
n Use of any component part not manufactured or approved by
Montigo in combination with this Montigo fireplace system.
n
Installation other than as instructed in this manual.
Consult your local Gas Inspection Branch on installation requirements
for factory-built gas fireplaces. Installation & repairs should be done by
a qualified contractor.
Installations in Canada must conform to the current CAN/CGA B-
149.1 and .2 Gas Installation Code and local regulations. If the optional
air-circulating fan kit is installed, it must be electrically grounded in
accordance with CSA C22.1 Canadian Electrical Code Part 1 and/or
Local Codes.
Installations in the USA must conform to local codes, or in the
absense of local codes to the National Fuel Gas Code, ANSI Z223.1-
1988. If the optional air-circulating fan is installed, it must be grounded
in accordance with local codes or, in the absence of local codes, with
the National Electrical Code, ANSI/NFPA 70-1987.
Table Of Contents
Introduction ............................................................................. 2
Installation
Installing the Fireplace Shell ........................................... 3
Installing the Gasline ...................................................... 4
The Remote Switch ....................................................... 4
Direct Vent Installation ................................................... 4
General Requirements ...................................... 4
Terminations ..................................................... 4
Top Vent Models with horizontal venting ............ 6
Top Vent Models with vertical venting ................ 8
Rear Vent Models ............................................. 9
Construction around the fireplace
Facing ............................................................. 11
Mantels and Surrounds ................................... 11
Wiring ....................................................................... 11
Removing and Installing the Door ................................ 12
Installing the Logset ..................................................... 13
Installing the Horizontal Trim........................................ 13
Operation ........................................................................ 14 - 16
Maintenance ................................................................... 16 - 17
Warranty ................................................................................. 18
Appendix
A. Termination Locations ............................................. 19
CAUTIONS
Due to its high operating temperatures, the appliance
should be located out of traffic & away from furniture and
draperies.
n
Children and adults should be alerted to the hazards
of the high surface temperature, which could cause
burns or clothing ignition.
n
Young children should be carefully supervised when
they are in the same room as the appliance.
n
Clothing or other flammable materials should not be
placed on or near the appliance.