Engineering, inc – Vortech Ford SVT Contour/Mercury 2.5L V6 Cougar User Manual

Page 26

P/N: 4FS020-010

11JAN02 V2.0

(Cougar (4FS V2.0))

ENGINEERING, INC.

1650 PACIFIC AVENUE • CHANNEL ISLANDS, CA 93033-9901 • (805) 247-0226

FAX (805) 247-0669 • www.vortechsuperchargers.com • M-F 8:00 AM - 4:30 PM PST

16. FINAL CHECK

A. Reconnect the battery.
B. If your vehicle has gone over 20,000 miles since

its last spark plug change, you will need to
change the spark plugs now

before test driving

the vehicle.

C. Check all fittings, nuts, bolts and clamps for

tightness. Pay particular attention to oil and fuel
lines near moving parts, sharp edges and ex-
haust system parts. Make sure all wires and lines
are properly secured with clamps or tie wraps.

D. Check all fluid levels, making sure that your

tank(s) is/are filled with 91 octane or higher fuel
before commencing test drive.

Start engine and allow to idle a few minutes, then

shut off.

Recheck to be sure that no hoses, wires, etc. are

near exhaust system or moving parts and for
signs of any fluid leakage.

G. PLEASE TAKE SPECIAL NOTE: Operating the

vehicle without ALL the subassemblies com-
pletely and properly installed may cause FAIL-
URE OF MAJOR COMPONENTS.

H. Test drive the vehicle.
I.

Read the STREET SUPERCHARGER SYSTEM

OWNER’S MANUAL AND RETURN THE WAR-
RANTY REGISTRATION FORM within thirty
(30) days of purchasing your supercharger sys-
tem to qualify.