Glow-worm Energy Saver 80 - 100 and Gave Valve - Manual (Page 2)

2 221564F
General
Please read these instructions and follow them carefully for the
safe and economical use of your boiler.
Once the controls are set, the boiler is automatic in operation.
The Energysaver 80 and 100 Combi boilers are able to provide
room heating as part of a central heating system and domestic
hot water direct from the cold water supply, without the need for
secondary storage.
Gas Category
This boiler is for use only on G20 gas.
Gas Safety (Installation and Use) Regulations
In your own interests and that of safety, it is the Law that ALL
gas appliances are installed by a competent person in
accordance with the current issue of the above regulations.
Gas Testing and Certification
The boiler is tested and certificated for safety and performance.
It is, therefore, important that no alteration is made to the boiler
unless approved, in writing, by Hepworth Heating Ltd.
Any alteration not approved by Hepworth Heating Ltd., could
invalidate the certification, boiler warranty and may also infringe
the current issue of the Statutory requirements.
CE Mark
This boiler meets the requirements of Statutory Instrument, No.
3083 The Boiler Efficiency Regulations, and therefore is deemed
to meet the requirements of Directive 92/42/EEC on the efficiency
requirements for new hot water boilers fired with liquid or
gaseous fuels.
Type test for purposes of Regulation 5 certified by:
Notified body 0063.
Product/production certified:
Notified body 0063.
The CE Mark on this appliance shows compliance with:
1. Directive 90/396/EEC on the approximation of the Laws of
the Member States relating to appliances burning gaseous
fuels.
2. Directive 73/23/EEC on the harmonization of the Laws of the
Member States relating to electrical equipment designed for
use within certain voltage limits.
3. Directive 89/336/EEC on the approximation of the Laws of
the Members States relating to electromagnetic compatibility.
Control of Substances Hazardous to Health
Under Section 6 of The Health and Safety at Work Act 1974, we
are required to provide information on substances hazardous
to health.
The adhesives and sealants used in this appliance are cured
and give no known hazard in this state.
Refractory Ceramic Fibre
This product uses insulation material containing Refractory
Ceramic Fibre (RCF), which are man-made vitreous silicate
fibres. Excessive exposure to these materials may cause
temporary irritation to eyes, skin and respiratory tract,
consequently, it makes sense to take care when handling these
articles to ensure that the release of dust is kept to a minimum.
To ensure that the release of fibres from these RCF articles is
kept to a minimum, during installation and servicing we
recommend that you use a HEPA filtered vacuum to remove
any dust accumulated in and around the boiler before and after
working on the boiler. When replacing these articles we
recommend that the replaced items are not broken up, but are
sealed within heavy duty polythene bags, clearly labelled as
RCF waste. This is not classified as “hazardous waste” and
may be disposed of at a tipping site licensed for the disposal of
industrial waste.
Contents
Important Information
Introduction 3
Operating the Boiler 3
Clock Setting 5
General Information 1 6
Boiler Position 2 8
Flue Location and Ventilation 3 9
Heating System 4 11
Domestic Hot Water System 5 13
Installation Preparation 6 13
Flue Preparation 7 15
Boiler Fixing 8 17
Gas, Water and Condensate Conns. 9 17
Electrical Connections 10 18
Commissioning 11 20
Servicing 12 25
Fault Finding 13 29
Replacement Parts 14 32
CONTENTS DESCRIPTION SECTION PAGE No.
INSTRUCTIONS
FOR USE
INSTALLATION
INSTRUCTIONS
SERVICING
INSTRUCTIONS