Troy-Bilt 12204-10HP - Manual (Page 61)

MODELS 12090,12204
Parts List
REF
No.
PART
No. DESCRIPTION QTY.
REF
No.
PART
No. DESCRIPTION QTY.
1 96515 Cable-battery, positive and negative 23 9265 Tie-plastic, wire retaining.... 1
terminals............................ 2 24 9009 Vent T ube-5/16" diameter... 1
2 97020 Boot-terminal insulating..... 3 25 1475 Shield-vent tube, 1/2" diameter... 1
3 9552 Screw-self-threading, 26 9224 Clamp-vent tube shield....... 1
1/4-20x1/2"......................... 3 27 9202 Tie-plastic.............................. 2
4 1186309 Bolt-hex hd„ 1/4-20x5/8"..... 2 28 1908118 Wire Harness & Connecting
5 1901894 Wire-recharge (red) for Briggs Terminal Assy-for Briggs & Stratton
and Stratton engine (inch engines(avaiiable as
terminal and eyelet).......... 1 complete assembly only). Incl.
6 1904564 Battery Hold-down Clamp-with wire assy., w/connector to large
attached Key Switch Plate (incl. solenoid stud (red wire); wire
Ref. No. 7).......................... 1 assy, w/connector to small
7 1904548 Decal-ignition switch instruc.. 1 solenoid stud (red wire); wire
8 1908112 Key Switch-includes two assy, w/connector to solenoid
ignition keys (Ref. No. 9), one grounding screw (red wire); wire
lockwasher, and one mounting assy w/connector to engine ground
nut (lock-washer and nut not shut-off (green wire); plastic
available separately)......... 1 protector tube; wire harness;
9 96520 Key-ignition, one pair.......... 1 connector; wire terminal.. 1
10 9566 Bolt-carriage, 1/4-20 x 1-1/4“... 2 29 1908117 Wire Harness-for Kohler engine.
11 1100241 Lockwasher-spring lock, 1/4". 2 Incl. two receptacles; three red
12 1186229 Nut-hex, 1/4"-20.................... 4 wires (solenoid activate, battery
13 9092B Battery-12 volt, 30 amps., side- recharge, and starter switch);
vented, (incl. Ref. No. 24,4,12)1 two green (ground)(shutoff)
14 96514 Solenoid-starter, includes nuts and wires; plastic harness tube.....1
washers for cables and wires... 1 30 1186389 Locknut-hex, 1/4“-20............ 2
15 1100242 Lockwasher-5/16"................ 2 32 1901202 Cable-ground, solenoid to engine
16 1186211 Nut-hex, 5/16"-24.................. 2 block................................... 1
17 1187559 Lockwasher-external tooth, #10.. 1 33 1186331 Bolt-flange lock, 5/16-18x1". 1
18 1186208 Nut-hex, #10-32.................... 1 34 1186391 Nut-flange lock, 5/16"-18..... 1
19 96510 Cable-solenoid to starter motor..1 35 1917269 Ground Wire Assembly....... 1
20 2571 Battery Bracket.................... 1
21 1186349 Bolt-flanged hex hd..
3/8-16x1-1/2“...................... 2
61