AERCO BMK 3.0 LN Dual Fuel Jan 2011 - Manual (Page 4)

CONTENTS
Chapter 5 – MODE OF OPERATION 5-1
Para. Subject Page
5.1 Introduction
5-1
5.2 Indoor/Outdoor Reset Mode 5-1
5.3 Constant Setpoint Mode 5-2
5.4 Remote Setpoint Mode 5-2
5.5 Direct Drive Modes 5-3
Para. Subject Page
5.6 Boiler Management System
(BMS)
5-4
5.7 Combination Control System
(CCS) 5-5
Chapter 6 – SAFETY DEVICE TESTING PROCEDURES 6-1
Para. Subject Page
6.1
Testing of Safety Devices 6-1
6.2 Natural Gas Low Gas Pressure
Switch Test 6-1
6.3 Propane Low Gas Pressure
Switch Test 6-2
6.4 Natural Gas High Gas Pressure
Switch Test 6-2
6.5 Propane High Gas Pressure
Switch Test 6-2
6.6 Low Water Level Fault Test 6-3
6.7 Water Temperature Fault Test 6-3
Para. Subject Page
6.8 Interlock Tests 6-4
6.9 Flame Fault Test 6-4
6.10 Air Flow Fault Test 6-5
6.11 SSOV Proof of Closure Switch 6-6
6.12 Purge Switch Open During
Purge 6-6
6.13 Ignition Switch Open During
Ignition 6-7
6.14 Safety Pressure Relief Valve
Test 6-7
Chapter 7 – MAINTENANCE REQUIREMENTS 7-1
Para. Subject Page
7.1 Maintenance
Schedule 7-1
7.2 Spark Ignitor 7-1
7.3 Flame Detector 7-3
7.4 Combustion Calibration 7-3
7.5 Safety Device Testing 7-3
7.6 Burner Inspection 7-3
Para. Subject Page
7.7 Condensate Drain Trap 7-4
7.8 Shutting the Boiler Down For An
Extended Period of Time 7-5
7.9 Placing The Boiler Back In
Service After A Prolonged
Shutdown 7-5
Chapter 8 – TROUBLESHOOTING GUIDE 8-1
Para. Subject Page
8.1 Introduction
8-1
Para. Subject Page
ii