Magliner COOLIFT - Manual (Page 12)

1-800-MAGLINE (624-5463) Page 12 www.magliner.com
CooLift
®
Battery*
General Battery Warnings:
• Do not connect accessories to the battery; this will cause
premature battery failure.
• Unauthorized modification could create a hazardous
condition and result in serious injury.
• Batteries contain sulfuric acid, which can burn eyes,
skin, clothes, etc. Use caution! Always wear gloves
when working with batteries. If contact occurs, flush
immediately with water and get medical attention.
Protect surfaces from battery damage by placing
batteries on rubber or plastic surfaces.
• To prevent electrical shock, do not touch non-insulated
parts of the charger output connectors, battery
connectors or battery terminals. Do not use connectors
that are cracked, corroded, or do not make adequate
electrical contact. Use of damaged or defective
connectors could result in fire or electrical shock.
• Keep sparks, flame and smoking materials away from
batteries.
• Batteries can supply a large amount of current. Do not wear jewelry or watches when working on
the batteries as an accidental shorting could occur and cause severe burning.
• Only qualified technicians should service your Magliner CooLift power supply system.
• Disconnect the battery box by unplugging the main wiring harness before attempting to replace
any electrical components.
• Only use authorized Magliner CooLift replacement parts.
Battery Life
The Magliner CooLift is powered by two 12-volt storage batteries. The pump motor draws current
from the batteries based on the amount of effort required to meet load being lifted. Testing and
research has been done to ensure a fully-charged battery will allow the user to go through a normal
workday without recharging the system; however, extreme temperature ranges and extreme loads
can have an effect on the amount of power available during one charging cycle.
NOTE: The battery must be charged within 6 months of storage to prevent self-discharge. If the
battery is not charged within 6 months of storage, permanent loss of capacity may occur.
Battery Charging
A built-in Magliner AC charger (part #63004 when using a common 120v domestic or 230v
international outlet) is capable of safely charging your CooLift battery. This charger uses standard
household power.
NOTE: When using the AC charger, please move the red switch (located next to the power switch) to
the voltage that is normal to your location.