Great Plains 2N-3010 Operator Manual - Manual (Page 2)

Table of Contents
© Copyright 1999 All rights Reserved
Great Plains Manufacturing, Inc. provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation
of this manual, Great Plains Manufacturing, Inc. assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the informa-
tion contained herein. Great Plains Manufacturing, Inc. reserves the right to revise and improve its products as it sees fit. This publication describes the state of this product at the
time of its publication, and may not reflect the product in the future.
Great Plains Manufacturing, Incorporated Trademarks
The following are trademarks of Great Plains Mfg., Inc.: Application Systems, Ausherman, Land Pride, Great Plains, Seed-Lok
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
Great Plains Mfg., Inc.
Table of Contents
2N-2410 and 2N-3010 Folding No-Till Drill 196-126M 12/27/05
Important Safety Information . . . . . . . . . . . . . . . . . . 1
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Description of Unit . . . . . . . . . . . . . . . . . . . . . . . . 9
Intended Usage . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . 9
Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . 9
Section 1 Drill Preparation and Setup . . . . . . . . . . 10
Prestart Checklist . . . . . . . . . . . . . . . . . . . . . . . . 10
Hitch Height Adjustment . . . . . . . . . . . . . . . . . . . 10
Installing Drill Control Consoles. . . . . . . . . . . . . . 11
Bleeding Hydraulic Systems . . . . . . . . . . . . . . . . 11
Field-Lift Hydraulics. . . . . . . . . . . . . . . . . . . . 11
Transport-Lock Hydraulics. . . . . . . . . . . . . . . 11
Raise-To-Fold Hydraulics . . . . . . . . . . . . . . . 12
Fold Hydraulics . . . . . . . . . . . . . . . . . . . . . . . 12
Marker Hydraulics . . . . . . . . . . . . . . . . . . . . . 13
Frame Leveling Adjustment . . . . . . . . . . . . . . . . . 13
Aligning Boxes . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Section 2 Operating Instructions 15
Prestart Checklist . . . . . . . . . . . . . . . . . . . . . . . . 15
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . 15
Recommended Minimum Tractor Size . . . . . 15
Minimum Towing Vehicle Weight . . . . . . . . . . 15
Hydrualics . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Safety Lights . . . . . . . . . . . . . . . . . . . . . . . . . 15
Hitching Tractor to Drill . . . . . . . . . . . . . . . . . . . . 15
Operating Control Console . . . . . . . . . . . . . . . . . 16
Operating Electric Clutch Consoles. . . . . . . . . . . 16
Folding the Drill . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Folding Harrow Attachment. . . . . . . . . . . . . . 16
Unfolding the Drill . . . . . . . . . . . . . . . . . . . . . . . . 16
Lifting the Drill in the Field . . . . . . . . . . . . . . . . . . 17
Field Operations . . . . . . . . . . . . . . . . . . . . . . . . . 17
Opener Operation . . . . . . . . . . . . . . . . . . . . . 17
Marker Operation . . . . . . . . . . . . . . . . . . . . . 17
Shaft Monitor Operation . . . . . . . . . . . . . . . . 18
Electric Clutch Operation . . . . . . . . . . . . . . . 18
Transporting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Section 3 Adjustments . . . . . . . . . . . . . . . . . . . . . . 19
No-Till Seeding . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Coulter Adjustments . . . . . . . . . . . . . . . . . . . . . . 19
Hydraulic Depth Control . . . . . . . . . . . . . . . . . . . 19
Electric Clutch Switch Adjustment . . . . . . . . . . . 20
Weights. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Coulter Springs. . . . . . . . . . . . . . . . . . . . . . . . . . 21
Individual Coulters . . . . . . . . . . . . . . . . . . . . 21
Opener Down-Pressure Adjustment. . . . . . . . . . 22
Press Wheel Adjustment . . . . . . . . . . . . . . . . . . 22
Setting the Seeding Rate . . . . . . . . . . . . . . . . . . 22
Small Seeds Attachment . . . . . . . . . . . . . . . . . . . 23
Seed Rate Charts. . . . . . . . . . . . . . . . . . . . . . . . . 24
Small Seeds Attachment Seed Rate Chart . . . . . 32
Gauge-Wheel Drive Adjustment . . . . . . . . . . . . . 34
Disk Scraper Adjustment . . . . . . . . . . . . . . . . . . 34
Leveling Adjustment . . . . . . . . . . . . . . . . . . . . . . 34
Marker Adjustments . . . . . . . . . . . . . . . . . . . . . . 34
Marker Chain . . . . . . . . . . . . . . . . . . . . . . . . 34
Disk Adjustment . . . . . . . . . . . . . . . . . . . . . . 35
Folding Speed . . . . . . . . . . . . . . . . . . . . . . . 35
Coulter Tines . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Harrow Attachment Adjustment . . . . . . . . . . . . . 36
Seed-Lok . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Section 4 Troubleshooting . . . . . . . . . . . . . . . . . . . 37
Section 5 Maintenance and Lubrication . . . . . . . . 40
General Maintenance . . . . . . . . . . . . . . . . . . . . . 40
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Section 6 Options . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Coulter Tines . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Weight Brackets . . . . . . . . . . . . . . . . . . . . . . . . . 45
Shaft Monitors . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Markers. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Small Seeds Attachment . . . . . . . . . . . . . . . . . . 46
Rear Mount Boom . . . . . . . . . . . . . . . . . . . . . . . 47
Harrow Attachment. . . . . . . . . . . . . . . . . . . . . . . 47
Seed Box Agitator. . . . . . . . . . . . . . . . . . . . . . . . 48
Seed-Lok Firming Wheels . . . . . . . . . . . . . . . . . 48
Seed-Cup Plugs . . . . . . . . . . . . . . . . . . . . . . . . . 48
Section 7 Specifications and Capacities . . . . . . . 49
Appendix . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Tire Inflation Chart . . . . . . . . . . . . . . . . . . . . . . . 50
Torque Values Chart for Common Bolt Sizes . . . 50
Electric Clutch and Wire Harness Diagram . . . . . 51
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53