Rockwell Automation SB3000 Universal Drive Controller Module - Manual (Page 20)

3-2 Universal Drive Controller Module
Step 4. Insert the module into the desired slot in the rack (refer to section 4.1 for
module restrictions). Use a screwdriver to secure the module into the rack.
Step 5. Use the following procedure to connect a fiber-optic cable (P/N 613613-xxR)
between the UDC module and the PMI:
a. Remove the dust cover caps from the fiber-optic ports on the UDC module
and the PMI.
b. Remove the dust cover caps from the fiber-optic cable’s connectors.
c. Store the dust cover caps in a safe place. The dust cover caps must be
re-installed on the fiber-optic ports and connectors whenever they are
disconnected.
d. Attach the cable’s connectors to the following ports as shown in figure 3.1.
• UDC module XMT port: blue fiber-optic cable
• UDC module RCV port: orange fiber-optic cable
• PMI XMT port: orange fiber-optic cable
• PMI RCV port: blue fiber-optic cable
Note that the fiber-optic cables are color-coded. Typically, the cables are
orange and blue. The cables used in your installation may be of a different
color but they should be installed in the same manner as described here.
Align the connector’s pin with the slot in the module’s port. See figure 3.2.
Push the connector onto the port. Turn the connector clockwise until it locks
onto the port’s two pins. Refer to the Fiber Optic Cabling instruction manual
(S-3009) for additional information.
!
$77(17,217XUQ RII ORFNRXW DQG WDJ WKH SRZHU WR ERWK WKH UDFN
FRQWDLQLQJ WKH 8'& PRGXOH DQG WR LWV FRUUHVSRQGLQJ 30, KDUGZDUH
EHIRUH YLHZLQJ WKH ILEHURSWLF FDEOH RU WUDQVPLWWHU XQGHU PDJQLILFDWLRQ
9LHZLQJ D SRZHUHG ILEHURSWLF WUDQVPLWWHU RU FRQQHFWHG FDEOH XQGHU
PDJQLILFDWLRQ PD\ UHVXOW LQ GDPDJH WR WKH H\H )RU DGGLWLRQDO LQIRUPDWLRQ
UHIHU WR $16, SXEOLFDWLRQ ] )DLOXUH WR REVHUYH WKLV SUHFDXWLRQ
FRXOG UHVXOW LQ ERGLO\ LQMXU\
$77(17,21'R QRW GDPDJH WKH HQGV RI WKH ILEHURSWLF FDEOH FRQQHFWRUV
E\ WRXFKLQJ RU GURSSLQJ WKHP 'R QRW XVH IDFWRU\FRPSUHVVHG DLU WR FOHDQ
WKH ILEHURSWLF SRUWV RU FRQQHFWRUV EHFDXVH WKH DLU PD\ FRQWDLQ LPSXULWLHV
WKDW FRXOG VFUDWFK WKHP )DLOXUH WR REVHUYH WKLV SUHFDXWLRQ FRXOG UHVXOW
LQ GDPDJH WR RU GHVWUXFWLRQ RI WKH HTXLSPHQW
!
$77(17,21'R QRW EHQG RU NLQN WKH FDEOH ZKHQ \RX DWWDFK LW WR WKH
SRUW %HQGLQJ WKH FDEOH VKDUSO\ FRXOG EUHDN WKH ILEHU LQVLGH )DLOXUH WR
REVHUYH WKLV SUHFDXWLRQ FRXOG UHVXOW LQ GDPDJH WR RU GHVWUXFWLRQ RI WKH
HTXLSPHQW