Multiquip WTE5C Operation Manual - Manual (Page 7)

WT5C/WTe5C WaTer Trailer • operaTion manual — rev. #1 (06/05/13) — page 7
safety information
pump SaFeTy
Danger
„ never operate the equipment in an explosive
atmosphere or near combustible materials. An
explosion or fi re could result causing severe
bodily harm or even death.
Warning
„ Accidental starting can cause severe injury
or death. ALWAYS place the ON/OFF
switch in the OFF position.
„ Do noT place hands or fingers inside
pump when pump is running.
„ never disconnect any emergency or
safety devices. These devices are intended for operator
safety. Disconnection of these devices can cause severe
injury, bodily harm or even death. Disconnection of any
of these devices will void all warranties.
CauTion
„ Be careful of discharge whipping under pressure.
NOTICE
„ never leave an open pump chamber unattended.
„ ALWAYS keep the machine in proper running condition.
„ Do noT attempt to thaw-out a frozen pump by using
a torch or other source of fl ame. Application of heat in
this manner may heat the oil in the seal cavity above the
critical point, causing pump damage.
„ Do noT pump water greater than 140° F.
„ Do noT pump liquids containing acid or alkali.
„ Do noT fi ll/pump heavy debris laden water.
„ Fix damage to machine and replace any broken parts
immediately.
„ ALWAYS store equipment properly when it is not being
used. Equipment should be stored in a clean, dry location
out of the reach of children and unauthorized personnel.
„ never lubricate components or attempt service on a
running machine.
„ ALWAYS allow the machine a proper amount of time to
cool before servicing.
„ Keep machine in proper running condition.
engine SaFeTy
Warning
„ Do noT place hands or fingers inside engine
compartment when engine is running.
„ never operate the engine with heat shields or
guards removed.
„ Do noT remove the engine oil drain plug
while the engine is hot. Hot oil will gush
out of the oil tank and severely scald any
persons in the general area of the pump.
CauTion
„ never touch the hot exhaust manifold,
muffl er or cylinder. Allow these parts to cool
before servicing equipment.
NOTICE
„ never run engine without an air fi lter or with a dirty air
fi lter. Severe engine damage may occur. Service air fi lter
frequently to prevent engine malfunction.
„ never tamper with the factory settings
of the engine or engine governor. Damage
to the engine or equipment can result
if operating in speed ranges above the
maximum allowable.