JLG 510AJ Parts Manual - Manual (Page 71)

SECTION 2 - TURNTABLE
3121182 510AJ 71
FIGURE 2-9. DEUTZ ENGINE INSTALLATION (BELGIUM BUILT MACHINES) (Prior to SN 1300000981)
ITEM PART NUMBER QTY DESCRIPTION REV
Ref Belgium Built Machines use SNs 13xxxxxxxx.
Ref Romanian Built Machines use SNs E3xxxxxxxx.
Ref DEUTZ ENGINE INSTALLATION
Ref 4WD Machines Options:Manufactured in Belgium (SN 1st digit
is 1)
0272490 Ref Belgium Built Machines (Prior to SN 1300000353) H
0273754 Ref Belgium Built Machines (SN 1300000353 through
1300000981) E
1 0100011 AR Compound, Locking
2 0100020 AR Sealant
4 0641406 1 Bolt 1/4in-20NC x 3/4in (Prior to SN 1300000178)
5 0641610 2 Bolt 3/8in-16NC x 1-1/4in
6 0642010 1 Bolt 5/8in-11NC x 1-1/4in
7 0902443 1 Bracket, Hood Latch Mount
8 0902444 1 Bracket, Hood Support
9 1320022 5 Clamp, Fuel Line
10 1320223 1 Clamp, J-Clip 1/2in (Prior to SN 1300000178)
11 2180536 1 Fitting, Straight (Prior to SN 1300000353)
12 2220250 1 Fitting, Reducer (Prior to SN 1300000353)
13 2220313 1 Fitting, Elbow
14 2220459 1 Fitting, Elbow (Prior to SN 1300000353)
15 2220794 1 Fitting, Straight (Prior to SN 1300000353)
16 2720058 15.1
ft/4.6m
Hose
17 2720271 12
ft/3.66m
Hose
18 2750532 7 ft/2.14m Hose
19 3311405 2 Locknut 1/4in-20NC
20 3312005 1 Locknut 5/8in-11NC
21 3340958 1 Pad, Wear
22 3900254 1 Bolt, Shoulder
23 4751400 12 Flatwasher 1/4in Regular
24 4751600 6 Flatwasher 3/8in Regular
25 4752000 1 Flatwasher 5/8in Regular
26 4752200 2 Flatwasher 3/4in Regular
27 0641418 2 Bolt 1/4in-20NC x 2-1/4in
28 4641108 1 Valve, Dual Select (Use p/n 1001099391)
Ref Note: Original Equipment Valve may have been replaced
with Service Replacement Valve. Identify p/n stamped on
valve before ordering parts.
28A 7012974 1 Cartridge without Coil (4641108 Valve)
28A 7010543 1 Seal Kit - 7012974 Cartridge
28A 7012941 1 Cartridge without Coil (1001099391 Valve)
28A 7010543 1 Seal Kit - 7012974 Cartridge
28A 7012944 1 Coil
28B 7012995 1 Cartridge without Coil
28B 7012518 1 Seal Kit - 7012995 Cartridge
28B 7012943 1 Coil
29 0181727 1 Angle, Battery Tie-Down (Prior to SN 1300000238)
30 Ref Battery (Wet)
30 0400075 1 Battery (Wet) (Use p/n 8008750) (Prior to SN 1300000238)