Snorkel TB125J - Manual (Page 30)

Chapter 7 – Prestart Inspection
30 T125J/TB125J – 0192214
Figure 7.3 – Fuel Tank
Use the following procedure to change the LPG tank.
1. Close the shutoff valve (refer to Figure 7.4).
Figure 7.4 – LPG Tank
2. Remove the fuel line from the tank using the quick
disconnect fitting.
3. Pull outward on each latch to release the straps
from the tank.
4. Carefully lift the tank from the cradle.
5. Place a full tank in the cradle making sure the slot
in the tank aligns with the pin.
6. Latch both straps to secure the tank.
7. Connect the fuel line and open the shutoff valve.
Fuel Line
Visually inspect the entire length of the fuel line. Start at
the fuel tank and trace the line to the engine inspecting
for leaks and damage.
Air Filter
The air filter gauge (refer to Figure 7.5) has an indicator
to show when the filter needs replaced.
Figure 7.5 – Lower Controls
To inspect the air filter:
1. Turn the battery disconnect switch on and close the
cowling door.
2. On dual fuel machines, set the fuel switch to either
LPG or gasoline.
3. At the lower controls, pull the emergency stop button
outward.
4. Insert the key into the controls switch and turn the
start switch to turn the engine on.
5. Set the throttle switch to the mid-throttle position.
6. Check the clear zone after running the engine for
30 seconds.
• If the indicator is red, replace the filter.
• If the indicator is clear, the filter is OK.
7. Shut off the engine.
Charging System
When the engine is running, the ammeter needle (refer
to Figure 7.5) should be to the right of “0.” Left of the
“0” is discharging.
Electrical System
Electrical power is supplied from three, 550 CCA, 12 volt
batteries. The batteries are behind the door on the left
side of the turntable (refer to Figure 7.6). These batteries
supply 12 volt DC electrical power to operate the aerial
platform electrical and electrohydraulic components,
including the emergency power system.
Fuel Level
Air Filter Gauge
Reset Button
Ammeter
Shutoff Valve
Quick
Disconnect
Fitting
Slot
Pin