Mountain Off Road 7686-2 - Manual (Page 5)

Step 11: Test fit the front drive shaft. Chances are, it is too short. We have found that in most
cases, the slip yoke needs to have more travel. Call Tom Wood’s Custom Drive Shafts at 877-
497-4238 about how you should proceed. DO NOT TRY TO SHORT CUT THIS STEP OR
DAMAGE WILL OCCUR TO YOUR DRIVE TRAIN.
Step 12: Check the front brake hoses. Make sure there is plenty of slack for suspension move-
ment. Have a helper turn the steering wheel from look to lock and watch them. If questionable,
longer hoses must be installed. M.O.R.E.™ recommends Skyjacker® brand brake hoses.
Step 13: Install the wheels/tires and remove the jack stands. With the Jeep® on the ground,
jump up and down on the front bumper several times to “seat” the suspension. Now, tighten
items "M" & "O" to 30 lbs. ft. torque. Tighten items "G” & "H" to NO MORE THEN 10 lbs. ft.
TORQUE! (It is very common to over-tighten the shackle bolts, don't do it!!!).
Step 14: Test drive the Jeep. It may be necessary to center the steering wheel by adjusting the
drag-link. Re-check all hardware for proper torque after 50 miles and EVERY off-road use. If you
have any questions, please call M.O.R.E.™.
TERMS-POLICIES:
DAMAGE CLAIMS: All orders are carefully packed, however, mishandling by the carrier can result in damage. The carrier has the
responsibility for the shipment from the time it leaves our warehouse until it is delivered to you. All claims for lost or damaged goods
should be reported to the carrier, not to M.O.R.E.™ LLC.
RETURNS: No returns will be accepted without prior permission from M.O.R.E.™ LLC. After you receive a Return Goods Authoriza-
tion (RGA) number, merchandise must be returned prepaid and insured. A claim must be made with in 30 days from receipt of mer-
chandise. The original invoice or a copy with the RGA number written on must accompany all returns. A 20% restocking fee will be
charged on all parts returned for credit or refund unless merchandise is proven to be defective or was shipped wrong by M.O.R.E.™
LLC. No merchandise will be issued credit or refund if it has been installed, modified, used in any way or is in unsalable condition.
WARRANTY: All merchandise is warranted to be free from defects in materials and workmanship prior to installation. Any alteration
or improper use will void this warranty. Because all parts we sell are intended for use in heavy-duty applications it is not possible to
warrantee or guarantee the performance of any items. M.O.R.E.™ LLC. products and the products manufactured by others, which
we sell may be subject to an infinite variety of conditions due to the manner in which they are used, serviced and/or installed. Pur-
chasers and users of such products rely upon their own judgment as to the suitable use selection, service and installation of such
products.
PRODUCT DISCLAIMER: Modification of your vehicle to enhance performance with parts sold by M.O.R.E.™ LLC. may create a
dangerous condition which could cause serious bodily injury, and the buyer hereby expressly assumes all risks associated with any
such modifications. All parts sold by M.O.R.E.™ LLC. are for racing or off road use only. Mountain Off Road Enterprises Inc. will not
accept responsibility for personal injury or property damage arising from the failure of any parts manufactured or sold by M.O.R.E.™
LLC.
Specifications are subject to change without notice.
Jeep®, AMC®, CJ®, TJ ® , YJ®, Wrangler®, are registered trademarks of the DaimlerChrysler
.
M.0.R.E™, BombProof™, S.R.S.™, SlipLoc™, DoubleJointed™, RockProof™, are trademarks used by Mountain Off Road
Enterprises, LLC. The M.O.R.E.™ logo and these instructions are copyright© 1996-2008.
7686-2
Page 5