Figure 10 – Hyline Offroad TJ TUBE STEP ROCKER PANEL User Manual
Page 4
Step 10 - Using a C-Clamp or Vise Clamp, clamp the Tube Step Rocker to the body. Then using the 3/8” Transfer
Punch and hammer locate each of the 5 Holes. Carefully remove the Tube Step Rocker from the Jeep
and set to the side until drilling is complete.
Step 11 – Check for and move Wires, Carpet or other obstructions before drilling. Use the 3/8” Bit to drill the
5 holes that were located in Step 10. After drilling, remove all sharp burrs, wipe out all metal shavings
and touch up bare metal with clear aerosol spray or similar rust inhibitor.
Step 12 – Re-Install the Tube Step Rocker onto the Jeep the same way you did in
Step 7. Align the holes in the Tube Step Rocker with the holes you just
drilled and install the 3/8” x 1” Stainless Bolts with 3/8” Nuts. Use the
Rocker Panel Backup Strip behind the 4 Bolts under the door. (See Figure 10)
Step 13 – Re-Install all Body Mount Bolts that were
Previously removed. The very front body
Mount will be kept off until the opposite
Tube Step Rocker is installed. Tighten to Factory Specs.
Step 11 – Repeat Steps 1 – 13 on the opposite side. Recheck to make sure all bolts have been tightened. Check
again after about 50 driven miles.
Send your OFFROAD pictures to
. If we choose any one of your pictures to be used on
our website, We send you a FREE Hyline Offroad T-Shirt.
T:\Hyline Offroad, LLC\Installation Instructions\TJ-30TSR\TJ-30TSR Installation Instructions.doc
Page 4 of 4
REV 0 12/2/08
Installation instructions provided must be read and followed exactly when installing
product. Failure to do so could potentially result in injury or death of any occupants
in the vehicle. WEAR SEAT BELTS AT ALL TIMES WHEN DRIVING!
Though our products are rugged, they are primarily designed and built to enhance the appearance of the
vehicle and will not protect from death or injury in the event of an accident. Adhere to all vehicle
manufacturers specifications
Attention
Back Up Strip Behind Door
Panel. Chamfered Edge is
Located Toward Rear.