Blue Angel Pumps CBP33 - Manual

Please read and save these instructions. Read carefully before attempting to assemble, install,
operate or maintain the product described. Protect yourself and others by observing all safety
information. Failure to comply with instructions could result in personal injury and/or property
damage! Retain instructions for future reference.
For parts, product & service information
visit www.blueangelpumps.com 1
Description
The pedestal pump is designed for
indoor home sump applications. The unit
is equipped with an 8-ft long, 3-prong
grounding type power cord. Motor is air
cooled; it is not designed to operate
under water. A float switch is provided
for automatic pump operation. This
pump is not suitable for aquatic life.
Unpacking
Inspect this unit before it is used.
Occasionally, products are damaged
during shipment. If the pump or
components are damaged, return the
unit to the place of purchase for
replacement. Failure to do so could
result in serious injury or death.
Safety Guidelines
This manual contains information that
is very important to know and
understand. This information is
provided for SAFETY and to PREVENT
EQUIPMENT PROBLEMS. To help
recognize this information, observe the
following symbols:
Danger
indicates
an imminently hazardous situation
which, if not avoided, will result in
death or serious injury.
Warning
indicates
a potentially hazardous situation
which, if not avoided, COULD result in
death or serious injury.
Caution
indicates
a potentially hazardous situation
which, if not avoided, MAY result in
minor or moderate injury.
Notice
indicates
important information, that if not
followed, may cause damage to
equipment.
Operating Instruction and Parts Manual Pedestal Series
360506-002 1/08
General Safety
Information
CALIFORNIA PROPOSITION 65
This
product
or its power cord may contain chemicals
known to the State of California to
cause cancer and birth defects or other
reproductive harm. Wash hands after
handling.
GENERAL SAFETY INOFRMATION
1. Read these rules and
instructions carefully.
Failure to follow these
instructions could cause
serious bodily injury and/or property
damage.
Do not
submerge
motor or allow motor to be exposed to
water. Personal injury and/or death could
result.
Do not use to pump
flammable or explosive fluids
such as gasoline, fuel oil,
kerosene, etc. Do not use in a flammable
and/or explosive atmosphere. Pump
should only be used to pump clear water.
Personal injury and/or death could result.
This
pump is
not designed to handle salt water, brine,
laundry discharge or any other
application which may contain caustic
chemicals and/or foreign materials. Pump
damage could occur if used in these
applications and will void warranty.
All wiring
must be
performed by a qualified electrician.
If the basement has water or
moisture on the floor, do not
walk on wet area until all
power is turned off. If the shutoff box is
in the basement, call an electrician.
Remove pump and either repair or
replace. Failure to follow this warning
could result in fatal electrical shock.
A battery
backup
system should be used. Call 1-888-636-
6628 to order an emergency backup
system.
Assembly
Always disconnect the power
source before attempting to
install, service, relocate or
maintain the pump. Never touch sump
pump, pump motor, water or discharge
piping when pump is connected to
electrical power. Never handle a pump or
pump motor with wet hands or when
standing on wet or damp surface or in
water. Fatal electrical shock could occur.
1. Insert the float rod through hole in
the switch lever (See Figure 1).
2. Place rubber grommet on float rod in
temporary position.
3. Using pliers to hold the float rod,
screw the float on as shown in
Figure 1.
Pedestal Sump Pump
Figure 1
© 2008 Blue Angel™ Pumps
REMINDER: Keep your dated proof of purchase for warranty purposes! Attach it to this manual or file it for safekeeping.