Stuart Turner WC1 Toilet only Macerator - Manual (Page 12)

- 12 -
6 MAINTENANCE
6.11 The macerator should only be used for the removal of normal human
waste, toilet paper and household WC cleaners.
6.12 AVOID COTTON WOOL, SANITARY TOWELS, TAMPONS, WET
WIPES,PAPER TOWELS,CONDOMS, HAIR, FOOD WASTE,
PLASTIC BAGS, NAPPIES, CIGARETTES ETC, as this will damage
the unit.
6.13 Do not pour in any corrosive liquids such as acids, solvents, oil,
paint stripper, as this will damage the unit, and is NOT covered under
the guarantee.
6.14 Acid based descalents and aggressive cleaning agents must not come
into contact with the unit.
If in any doubt as to the suitability of the chemical solutions, please
contact our Pump Assist Helpline.
6.15 As water is heated scale deposits are released in areas of hard water.
Scale can cause the mechanical seal to stick if left unused for long
periods. We recommend the unit to be run every four weeks to
“exercise” all working parts.
It is also recommended that a non acid based descalent is used to
remove limescale. To be carried out twice a year.
6.16 There should be no dripping from the WC cistern or taps, as this will
cause the unit to operate.
6.17 Do not use the toilet or connected sanitary device in the event of a
power failure.
6.18 The adhesive warning label (Fig. 1), as provided is to be fixed in a
visible area (suggest under toilet seat cover).
6.19 Should the unit start to release odours the charcoal
filter should be changed (Fig. 2).
6.20 No other maintenance is required under normal
working conditions.
WARNING: The macerator must be
disconnected from the power supply before
replacing the filter.
Contact Stuart Turner for spares replacement.
6.21 For Further Technical Support: Phone the Stuart Turner Pump Assist team
on 0844 98 000 97. Our staff are trained to help and advise you over the phone
or arrange for a service engineer to call.
Fig. 1
NO
FOREIGN
OBJECTS
Fig. 2
Charcoal
filter