Milton CAT G3516 1800 rpm 1040 kW 60 Hz Spec Sheet - Manual

CATERPILLAR ® ENGINE SPECIFICATIONS
V-16, 4-Stroke-Cycle Spark-Ignited
Bore — in (mm) . . . . . . . . . . . . . . . . . . . . . 6.7 (170)
Stroke — in (mm) . . . . . . . . . . . . . . . . . . . 7.5 (190)
Displacement — cu in (L). . . . . . . . . . . 4210 (67.4)
Aspiration . . . . . . . . . Turbocharged-Aftercooled
Compression ratio . . . . . . . . . . . . . . . . . . . . . . . 11:1
CATERPILLAR ® SR4B GENERATOR
Type . . . . . . . . . Static regulator, brushless excited
Construction . . . . . . Single bearing, close coupled
Three phase . . . . . . . . . . . . . . . . . . . Wye connected
Insulation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Class H
Enclosure. . . . . . . . . . . . . Drip proof IP/22, guarded
Alignment . . . . . . . . . . . . . . . . Caterpillar pilot shaft
Overspeed capability. . . . . . . . . . . . . . . . . . . . . 150%
Waveform . . . . . . . . . . . . . . Less than 5% deviation
Voltage regulator . . . . . . . . . 3-phase sensing with
Volts-per-Hertz response
Voltage regulation . . . . . . . . . . . . . . Less than ± 1%
Voltage gain . . . . . . Adjustable to compensate for
engine speed droop and line loss
TIF . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Less than 50
THF . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Less than 5%
CATERPILLAR CONTROL PANEL
24 Volt DC Control
Terminal box mounted
Vibration isolated
NEMA 1/IP 22 enclosure
Electrically dead front
Lockable door
Generator instruments meet ANSI C-39-1
Voltages Available
60 Hz
240, 480
(Adjustable a minimum of ±10%)
Other voltages available – consult your Caterpillar
dealer.
Some voltages require derating.
Gas
Generator
Set
FEATURES
G3516
1800 rpm
1040 ekW 60 Hz
Standby Power
■ CATERPILLAR ® FACTORY PACKAGE
Factory designed, assembled, and tested.
Supported by Caterpillar parts and labor
warranty through your local Caterpillar
dealer.
■ DIESEL STRENGTH BUILT IN
Blocks, crankshafts, liners, and connecting
rods are common with higher loaded Cat
®
diesel engines. Robust design provides
prolonged life at lower gas engine loads.
■ ELECTRONIC IGNITION SYSTEM WITH
DETONATION SENSITIVE TIMING
The Caterpillar Electronic Ignition System
(EIS) provides optimized spark timing for all
operating conditions. Timing is
automatically controlled to maintain
continuous detonation protection.
■ LOW EXHAUST EMISSIONS
2.0 gram/bhp-hr NO
x
. Lower emissions are
achievable for selected applications;
consult your Caterpillar dealer.
Shown with
Optional Equipment