Milton CAT G3516 1800 rpm 1300 kW 60 Hz Spec Sheet - Manual (Page 4)

C O N T I N U O U S 1 3 0 0 e k W
1 4 0 0 e k W
6 0 H z
LEHE2033-01
4
TECHNICAL DATA
* *Assumes synchronous driver.
**Emissions data measurements are consistent with those described in EPA CFR 40 Part 89 Subpart D & E and ISO8178-1 for
measuring HC, CO, PM, NOx. Data shown is based on steady state engine operating conditions of 25° C (77° F), 96.28 kPa
(28.43 inches Hg) and fuel having a LHV of 35.6 mJ/N•m
3 (905 Btu/cu.ft) at 101.60 kPa (30.00 inches Hg) absolute and 0° C (32° F).
Not to exceed emission data shown is subject to instrumentation, measurement, facility and engine fuel system adjustments.
Generator Set — 1800 rpm/60 Hz/480 Volts DM5497 DM5495
G3516B LE Gas Generator Set
Emission level (NOx) g/bhp-hr 1.0 1.0
Aftercooler — SCAC temperature Deg C Deg F 32 90 54 130
Package Performance
Power rating @ 1.0 pf (unity) ekW 1410 1310
Power rating @ 0.8 pf (3) ekW 1400 1300
kVA 1750 1625
Fuel Consumption (1)
100% load 60 without fan N•m 3 /hr scf/hr 396 14,770 369 13,789
75% load 60 without fan N•m 3 /hr scf/hr 312 11,650 288 10,737
50% load 60 without fan N•m 3 /hr scf/hr 223 8321 208 7777
Electrical Efficiency % 36.3 35.7
Altitude Capability (2)
At 25° C/77° F ambient M ft 872 2862 903 2961
Cooling System
Ambient air temperature Deg C Deg F 25 77 25 77
Jacket water temperature (maximum outlet) Deg C Deg F 92 198 92 198
Exhaust System
Combustion air inlet flow rate N•m 3 /min scfm 110 4117 105 3926
Exhaust stack gas temperature Deg C Deg F 532 990 530 986
Exhaust gas flow rate N•m 3 /min cfm 342 12,064 325 11,469
Exhaust flange size (internal diameter) mm in 203 8 203 8
Heat Balance (2) (3)
Low Heat Value (LHV) fuel input kW Btu/min 4032 229,357 3764 214,100
Heat rejection to jacket water (total) kW Btu/min 783 45,511 764 43,448
Heat rejection to exhaust (LHV to 350° F) kW Btu/min 958 54,471 906 51,547
Heat rejection to A/C — Stage 2 kW Btu/min 180 10,211 118 6717
Heat rejection to atmosphere from engine kW Btu/min 137 7793 136 7762
Heat rejection to atmosphere from generator kW Btu/min 44 2523 43 2432
Alternator
Motor starting capability @ 30% voltage dip* KVA 3271 2661
Frame 824 697
Temperature rise Deg C 105 105
Lube System
Lube oil refill volume w/filter change for standard sump L Gal 401 106 401 106
Emissions**
NOx g/ghp-hr 1.0 1.0
CO g/ghp-hr 2.5 2.6
HC (total) g/ghp-hr 4.1 4.4
HC (non-methane) g/ghp-hr 0.62 0.66
Exhaust O
2
(dry) % 8.9 9.2