Power-Sonic PDC-121000 - Manual (Page 2)

Charging
Cycle Applications:Limitinitialcurrentto27A.Chargeuntilbatteryvoltage
(undercharge)reaches14.4to14.7voltsat68°F(20°C).Holdat14.4to14.7
voltsuntilcurrentdropstounder1000mA.Batteryisfullychargedunderthese
conditions, and charger should be disconnected or switched to “float” voltage.
“Float” or “Stand-By” Service:Holdbatteryacrossconstantvoltagesourceof
13.5 to 13.8 volts continuously. When held at this voltage, the battery will seek its
owncurrentlevelandmaintainitselfinafullychargedcondition.
Note:Duetotheself-dischargecharacteristicsofthistypeofbattery,itis
imperativethattheybechargedwithin6monthsofstorage,otherwisepermanent
lossofcapacitymightoccurasaresultofsulfation.
Chargers
Power-Sonicoffersawiderangeofchargerssuitableforbatteriesupto100AH.
Please refer to the Charger Selection Guide in our specification sheets for “C-Series
Switch Mode Chargers” and “Transformer Type A and F Series”. Please contact our
Technical department for advice if you have difficulty in locating suitable models.
Discharge Characteristics
PDC-121000 12 Volt 100.0 AH
@ 20-hr. rate
, 92.0 AH @ 10-hr. rate
®
Further Information
Pleaserefertoourwebsitewww.power-sonic.comforacompleterangeofuseful
downloads,suchasproductcatalogs,materialsafetydatasheets(MSDS),ISO
certification, etc..
1 2 4 6 8 10 20 40 60 2 4 6 8 10 20
min h
4.0
4.5
5.0
5.5
6
6V Battery
(V)
12V Battery
(V)
.0
6.5
0 200 400 600 800 1000 1200 1400 1600 1800
20
40
60
80
100
120
0
- 20 -10 0 10 20 30 40 50
0
20
40
60
80
100
120 0.10CA
0.12 CA
0.21CA
1CA
2CA
3CA
8 10 12
0
4 6
60
80
100
0 2
20
40
A
B
C
0 4 8 12 16 20 24 28
% (A) (V/cell)
Terminal V
oltage (V)
Capacity Ratio (%)
Capacity (%)
Remaining Capacity (%)
Temperature(°C)
Temperature: 25°C Charge
Volume
Charging
Current
Charged
Voltage Charge at 0.1C Amp Initial Charging Current and
2.45V/Cell Constant Voltage at 25°C
Discharge Time
Charging Time (Hours)
Number of Cycles
Storage Time (Months)
A
B
C
10°C
100%
DOD
50%
DOD
30%
DOD
30°C 40°C
No supplementary charge required
(Carry out supplementary charge before use if 100% capacity is required.)
Supplementary charge required before use.Optional charging way as below:
1.Charged for above 3 days at limted current 0.25CA and constant volatge 2.25V/cell.
2.Charged for above 20hours at limted current 0.25CA and constant volatge 2.45V/cell.
3.Charged for 8~10hours at limted current 0.05CA .
Supplementary charge may often fail to recover the capacity.
The battery should never be left standing till this is reached
25°C
Testing condition
Discharging:current 0.17C (FV 1.7V/cell);
Charging:current 2.45V/cell,max. 0.25CA;
Charging volume:125% of discharged capacity.
13.0
12.0 120
0.1C
0.08C
0.06C
0.04C
0.02C
2.5
2.4
2.3
2.2
2.1
0C
100
80
60
40
20
11.0
10.0
9.0
8.0
5.0A 9.0A
19.2A
35A
58.1A 99.0A 186A 340A
Charged Volume
Charge Voltage
(Constant 2.45V/Cell)
After 50% Discharge
After 100% Discharge
Charging Current
(Initial at 0.1C Amp)
1 2 4 6 8 10 20 40 60 2 4 6 8 10 20
min h
4.0
4.5
5.0
5.5
6
6V Battery
(V)
12V Battery
(V)
.0
6.5
0 200 400 600 800 1000 1200 1400 1600 1800
20
40
60
80
100
120
0
- 20 -10 0 10 20 30 40 50
0
20
40
60
80
100
120 0.10CA
0.12 CA
0.21CA
1CA
2CA
3CA
8 10 12
0
4 6
60
80
100
0 2
20
40
A
B
C
0 4 8 12 16 20 24 28
% (A) (V/cell)
Terminal V
oltage (V)
Capacity Ratio (%)
Capacity (%)
Remaining Capacity (%)
Temperature(°C)
Temperature: 25°C Charge
Volume
Charging
Current
Charged
Voltage Charge at 0.1C Amp Initial Charging Current and
2.45V/Cell Constant Voltage at 25°C
Discharge Time
Charging Time (Hours)
Number of Cycles
Storage Time (Months)
A
B
C
10°C
100%
DOD
50%
DOD
30%
DOD
30°C 40°C
No supplementary charge required
(Carry out supplementary charge before use if 100% capacity is required.)
Supplementary charge required before use.Optional charging way as below:
1.Charged for above 3 days at limted current 0.25CA and constant volatge 2.25V/cell.
2.Charged for above 20hours at limted current 0.25CA and constant volatge 2.45V/cell.
3.Charged for 8~10hours at limted current 0.05CA .
Supplementary charge may often fail to recover the capacity.
The battery should never be left standing till this is reached
25°C
Testing condition
Discharging:current 0.17C (FV 1.7V/cell);
Charging:current 2.45V/cell,max. 0.25CA;
Charging volume:125% of discharged capacity.
13.0
12.0 120
0.1C
0.08C
0.06C
0.04C
0.02C
2.5
2.4
2.3
2.2
2.1
0C
100
80
60
40
20
11.0
10.0
9.0
8.0
5.0A 9.0A
19.2A
35A
58.1A 99.0A 186A 340A
Charged Volume
Charge Voltage
(Constant 2.45V/Cell)
After 50% Discharge
After 100% Discharge
Charging Current
(Initial at 0.1C Amp)
1 2 4 6 8 10 20 40 60 2 4 6 8 10 20
min h
4.0
4.5
5.0
5.5
6
6V Battery
(V)
12V Battery
(V)
.0
6.5
0 200 400 600 800 1000 1200 1400 1600 1800
20
40
60
80
100
120
0
- 20 -10 0 10 20 30 40 50
0
20
40
60
80
100
120 0.10CA
0.12 CA
0.21CA
1CA
2CA
3CA
8 10 12
0
4 6
60
80
100
0 2
20
40
A
B
C
0 4 8 12 16 20 24 28
% (A) (V/cell)
Terminal V
oltage (V)
Capacity Ratio (%)
Capacity (%)
Remaining Capacity (%)
Temperature(°C)
Temperature: 25°C Charge
Volume
Charging
Current
Charged
Voltage Charge at 0.1C Amp Initial Charging Current and
2.45V/Cell Constant Voltage at 25°C
Discharge Time
Charging Time (Hours)
Number of Cycles
Storage Time (Months)
A
B
C
10°C
100%
DOD
50%
DOD
30%
DOD
30°C 40°C
No supplementary charge required
(Carry out supplementary charge before use if 100% capacity is required.)
Supplementary charge required before use.Optional charging way as below:
1.Charged for above 3 days at limted current 0.25CA and constant volatge 2.25V/cell.
2.Charged for above 20hours at limted current 0.25CA and constant volatge 2.45V/cell.
3.Charged for 8~10hours at limted current 0.05CA .
Supplementary charge may often fail to recover the capacity.
The battery should never be left standing till this is reached
25°C
Testing condition
Discharging:current 0.17C (FV 1.7V/cell);
Charging:current 2.45V/cell,max. 0.25CA;
Charging volume:125% of discharged capacity.
13.0
12.0 120
0.1C
0.08C
0.06C
0.04C
0.02C
2.5
2.4
2.3
2.2
2.1
0C
100
80
60
40
20
11.0
10.0
9.0
8.0
5.0A 9.0A
19.2A
35A
58.1A 99.0A 186A 340A
Charged Volume
Charge Voltage
(Constant 2.45V/Cell)
After 50% Discharge
After 100% Discharge
Charging Current
(Initial at 0.1C Amp)
1 2 4 6 8 10 20 40 60 2 4 6 8 10 20
min h
4.0
4.5
5.0
5.5
6
6V Battery
(V)
12V Battery
(V)
.0
6.5
0 200 400 600 800 1000 1200 1400 1600 1800
20
40
60
80
100
120
0
- 20 -10 0 10 20 30 40 50
0
20
40
60
80
100
120 0.10CA
0.12 CA
0.21CA
1CA
2CA
3CA
8 10 12
0
4 6
60
80
100
0 2
20
40
A
B
C
0 4 8 12 16 20 24 28
% (A) (V/cell)
Terminal V
oltage (V)
Capacity Ratio (%)
Capacity (%)
Remaining Capacity (%)
Temperature(°C)
Temperature: 25°C Charge
Volume
Charging
Current
Charged
Voltage Charge at 0.1C Amp Initial Charging Current and
2.45V/Cell Constant Voltage at 25°C
Discharge Time
Charging Time (Hours)
Number of Cycles
Storage Time (Months)
A
B
C
10°C
100%
DOD
50%
DOD
30%
DOD
30°C 40°C
No supplementary charge required
(Carry out supplementary charge before use if 100% capacity is required.)
Supplementary charge required before use.Optional charging way as below:
1.Charged for above 3 days at limted current 0.25CA and constant volatge 2.25V/cell.
2.Charged for above 20hours at limted current 0.25CA and constant volatge 2.45V/cell.
3.Charged for 8~10hours at limted current 0.05CA .
Supplementary charge may often fail to recover the capacity.
The battery should never be left standing till this is reached
25°C
Testing condition
Discharging:current 0.17C (FV 1.7V/cell);
Charging:current 2.45V/cell,max. 0.25CA;
Charging volume:125% of discharged capacity.
13.0
12.0 120
0.1C
0.08C
0.06C
0.04C
0.02C
2.5
2.4
2.3
2.2
2.1
0C
100
80
60
40
20
11.0
10.0
9.0
8.0
5.0A 9.0A
19.2A
35A
58.1A 99.0A 186A 340A
Charged Volume
Charge Voltage
(Constant 2.45V/Cell)
After 50% Discharge
After 100% Discharge
Charging Current
(Initial at 0.1C Amp)
Cycle Life in Relation to Depth of Discharge
1 2 4 6 8 10 20 40 60 2 4 6 8 10 20
min h
4.0
4.5
5.0
5.5
6
6V Battery
(V)
12V Battery
(V)
.0
6.5
0 200 400 600 800 1000 1200 1400 1600 1800
20
40
60
80
100
120
0
- 20 -10 0 10 20 30 40 50
0
20
40
60
80
100
120 0.10CA
0.12 CA
0.21CA
1CA
2CA
3CA
8 10 12
0
4 6
60
80
100
0 2
20
40
A
B
C
0 4 8 12 16 20 24 28
% (A) (V/cell)
Terminal V
oltage (V)
Capacity Ratio (%)
Capacity (%)
Remaining Capacity (%)
Temperature(°C)
Temperature: 25°C Charge
Volume
Charging
Current
Charged
Voltage Charge at 0.1C Amp Initial Charging Current and
2.45V/Cell Constant Voltage at 25°C
Discharge Time
Charging Time (Hours)
Number of Cycles
Storage Time (Months)
A
B
C
10°C
100%
DOD
50%
DOD
30%
DOD
30°C 40°C
No supplementary charge required
(Carry out supplementary charge before use if 100% capacity is required.)
Supplementary charge required before use.Optional charging way as below:
1.Charged for above 3 days at limted current 0.25CA and constant volatge 2.25V/cell.
2.Charged for above 20hours at limted current 0.25CA and constant volatge 2.45V/cell.
3.Charged for 8~10hours at limted current 0.05CA .
Supplementary charge may often fail to recover the capacity.
The battery should never be left standing till this is reached
25°C
Testing condition
Discharging:current 0.17C (FV 1.7V/cell);
Charging:current 2.45V/cell,max. 0.25CA;
Charging volume:125% of discharged capacity.
13.0
12.0 120
0.1C
0.08C
0.06C
0.04C
0.02C
2.5
2.4
2.3
2.2
2.1
0C
100
80
60
40
20
11.0
10.0
9.0
8.0
5.0A 9.0A
19.2A
35A
58.1A 99.0A 186A 340A
Charged Volume
Charge Voltage
(Constant 2.45V/Cell)
After 50% Discharge
After 100% Discharge
Charging Current
(Initial at 0.1C Amp)
Charging Characteristics (Cycle Use)
Temperature Effects in Relation to Battery Capacity
Self Discharge Characteristics
CORPORATE OFFICE • 7550 Panasonic Way • San Diego, CA 92154 • USA • Tel: +1-619-661-2020 • Fax: +1-619-661-3650
CUSTOMER SERVICE
Tel:+1-619-661-2030
Fax:+1-619-661-3648
[email protected]
INTERNATIONAL SALES
Tel: +1-650-364-5001
Fax: +1-650-366-3662
[email protected]
DOMESTIC SALES
Tel:+1-619-661-2020
Fax: +1-619-661-3650
[email protected]
TECHNICAL SUPPORT
Tel:+1-619-661-2020
Fax:+1-619-661-3648
[email protected]
Contact Information www.power-sonic.com
1012 1M
© 2012. Power-Sonic Corporation. All rights reserved. All trademarks are the property of their respective owners.