Yazoo/Kees ZMKW48172 - Manual (Page 50)

STORAGE
English - 50
Winter Storage
At the end of the mowing season, the machine should
be readied for storage (or if it will not be in use for
longer than 30 days). Fuel allowed to stand for long
periods of time (30 days or more) can leave sticky
residues that can plug the carburetor and disrupt
engine function.
Fuel stabilizers are an acceptable option as regards
sticky residues during storage.
Add stabilizer to the fuel in the tank or in the storage
container. Always use the mixing ratios specified by
the manufacturer of the stabilizer. Run the engine for
at least 10 minutes after adding the stabilizer so that it
reaches the carburetor. Do not empty the fuel tank and
the carburetor if you have added stabilizer.
To ready the machine for storage, follow these steps:
Thoroughly clean the machine, especially 1.
under the mower deck. Touch up damage
to the paint and spray a thin layer of oil on
the underside of the mower deck to avoid
corrosion.
Inspect the machine for worn or damaged
2.
parts and tighten any nuts or screws that may
have become loose.
Change the engine oil; dispose of properly.
3.
Empty the fuel tanks or add a fuel stabilizer. 4.
Start the engine and allow it to run until the
carburetor is drained of fuel or the stabilizer
has reached the carburetor.
Remove the spark plugs and pour about a
5.
tablespoon of engine oil into each cylinder.
Turn over the engine so that the oil is evenly
distributed and then refit the spark plugs.
Lubricate all grease zerks, joints, and axles.
6.
Remove the battery. Clean, charge, and store 7.
the battery in a cool place, but protect it from
direct cold.
Store the machine in a clean, dry place and
8.
cover it for extra protection.
Service
When ordering spare parts, please specify the
purchase year, model, type, and serial number.
Always use genuine Yazoo/Kees spare parts.
An annual checkup at an authorized service workshop
is a good way to ensure that your machine performs its
best the following season.
WARNING!
Never store an engine with fuel in the tank
indoors or in poorly ventilated spaces where
fuel vapor can come in contact with open
flames, sparks, or a pilot light such as in
a boiler, hot water tank, clothes drier, etc.
Handle the fuel with care. It is very flammable
and careless use can cause serious personal
injury and property damage. Drain the fuel
into an approved container outdoors and far
away from open flame. Never use gasoline
for cleaning. Use a degreaser and warm
water instead.