Lochinvar 000 through 2 - Manual (Page 55)

55
ƽ WARNING
Use a level to ensure that the condensate trap is level on its
base. Failure to keep the condensate trap level can result in the
spillage of flue products from the condensate trap.
Failure to follow this warning could result in product damage
or improper operation, personal injury, or death.
NOTE:
Use materials approved by the authority having jurisdiction.
In the absence of other authority, PVC and CPVC pipe must
comply with ASTM D1785 or D2845. Cement and primer
must comply with ASME D2564 or F493. For Canada use
CSA or ULC certified PVC or CPVC pipe, fittings, and
cement.
13. Slope the condensate line down and away from the
appliance into a drain or condensate neutralizing filter. Do not
expose the condensate line to freezing temperatures.
NOTE:
The condensate line must remain unobstructed, allowing
free flow of condensate. If condensate is allowed to freeze
in the line or if the line is obstructed in any other manner, the
blocked drain safety switch will prevent the appliance from
firing.
FIG. 73 Install Condensate Trap
LIGHTING INSTRUCTIONS
FOR YOUR SAFETY,
READ BEFORE
OPERATING
WARNING
ƽ
If the information in this manual is not followed exactly, a
fire or explosion may result causing property damage,
personal injury or loss of life.
A. This appliance does not have a pilot. It is
equipped with an ignition device which automati-
cally lights the burner. Do not try to light the
burner by hand.
B. BEFORE OPERATING, smell around the appliance
area for gas. Be sure to smell next to the
floor because some gas is heavier
than air and will settle to the floor.
• Do not try to light any appliance.
• Do not touch any electric switch; do not
use any phone in your building.
• Immediately call your gas sup pli er from a
neighbors phone.
• Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call
the fire department.
C. Use only your hand to turn the gas control
handle. Never use tools. If the handle will not
turn by hand, don’t try to repair it, call a
qualified service technician. Force or
attempted repair may result in a fire or
explosion.
D. Do not use this appliance if any part has been
under water. Im
me di ate ly call a qualified
service tech ni cian to inspect the boiler. The
possible damage to a flooded appliance can
be extensive and present numerous safe
ty
hazards. Any appliance that has been under
water must be replaced.