AERCO BMK 3.0 LN Dual Fuel July 2011 Instruction Manuals and User Guides
We have 1 Instruction Manual and User Guide for BMK 3.0 LN Dual Fuel July 2011 AERCO
Manuals 
| Recognized languages: | English |
|---|---|
| Pages: | 138 |
| Size: | 5.72 MB |
Show table of contents
Document Outline
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_01_CVR_10-04-12
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_02_TOC_4-29-10
- FOREWORD A
- Chapter 1 – SAFETY PRECAUTIONS 1-1
- Chapter 2 – INSTALLATION 2-1
- Chapter 3 – CONTROL PANEL OPERATING PROCEDURES 3-1
- Chapter 4 – INITIAL START-UP 4-1
- Chapter 5 – MODE OF OPERATION 5-1
- Chapter 6 – SAFETY DEVICE TESTING PROCEDURES 6-1
- Chapter 7 – MAINTENANCE REQUIREMENTS 7-1
- Chapter 8 – TROUBLESHOOTING GUIDE 8-1
- Chapter 9 - RS232 COMMUNICATION 9-1
- APPENDICES
- WARRANTIES W-1
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_03_Fwd_5-1-07
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_04_CH1-7-7-11
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_05_CH2_2-25-13-BB
- CHAPTER 2 installation
- 2.1 introduction
- 2.2 RECEIVING THE UNIT
- 2.3 UNPACKING
- 2.4 site PREPARATION
- 2.5 SUPPLY AND RETURN PIPING
- 2.6 Condensate drains
- 2.7 GAS SUPPLY PIPING
- 2.8 AC ELECTRICAL power wiring
- 2.9 MODEs OF OPERATION and FIELD CONTROL WIRING
- 2.10 I/O BOX CONNECTIONS
- 2.11 AUXILIARY RELAY CONTACTS
- 2.12 FLUE GAS VENT INSTALLATION
- 2.13 COMBUSTION AIR
- CHAPTER 2 installation
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_06_Ch3_4-18-11-BB
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_07_CH4_2-25-13-BB
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_08_CH5_6-1-10-BB
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_09_CH6_3-22-11-BB
- CHAPTER 6 safety device testing
- 6.1 TESTING OF SAFETY DEVICES
- 6.2 NATURAL GAS LOW GAS PRESSURE SWITCH TEST
- 6.3 propane LOW GAS PRESSURE SWITCH TEST
- 6.4 natural gas HIGH GAS PRESSURE switch TEST
- 6.5 propane HIGH GAS PRESSURE switch TEST
- 6.6 LOW WATER LEVEL FAULT TEST
- 6.7 WATER TEMPERATURE FAULT TEST
- 6.8 INTERLOCK TESTS
- 6.9 FLAME FAULT TESTs
- 6.10 AIR FLOW FAULT TESTS
- 6.11 SSOV PROOF OF CLOSURE SWITCH
- 6.12 PURGE SWITCH OPEN DURING PURGE
- 6.13 IGNITION SWITCH OPEN DURING IGNITION
- 6.14 SAFETY PRESSURE RELIEF VALVE TEST
- CHAPTER 6 safety device testing
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_10_CH7_4-23-10-BB
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_11_Ch8_6-1-10-BB
- Chapter 8- TROUBLESHOOTING GUIDE
- 1. Measure the actual exhaust temperature and continuity of the exhaust sensor. If the exhaust temperature is less than 475 o F and the exhaust sensor shows continuity replace the sensor.
- 2. If exhaust temperature is greater than 500 o F, check combustion calibration. Calibrate or repair as necessary.
- 2. If gas supply pressure downstream of SSOV cannot be lowered, to 1.5” W.C. (see para. 4.3, step 10), the SSOV Supply Regulator may be defective
- 2. If there are two external wires on these terminals check any Energy Management system to see if they have the units disabled (a jumper may be temporarily installed to see if the interlock circuit is functioning).
- 3. Verify that the proving switch for any device hooked to the interlock circuit is closing and that the device is operational.
- TABLE 8-1. BOILER TROUBLESHOOTING – Continued
- TABLE 8-1. BOILER TROUBLESHOOTING – Continued
- TABLE 8-1. BOILER TROUBLESHOOTING – Continued
- TABLE 8-1. BOILER TROUBLESHOOTING – Continued
- TABLE 8-2. BOILER TROUBLESHOOTING WITH NO FAULT MESSAGE DISPLAYED
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_12_CH9_6-2-10
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_13_APP-A_3-21-11
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_14_APP-B_10-1-09-bb
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_15_APP-C_3-19-10
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_16_APP-D_8-14-06
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_17_App-E_3-21-11
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_18_App-F_7-15-11-BB
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_19_APP-G
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_20_APP-H_1-27-11-BB
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_21_App-I_6-7-10
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_22_App-J_10-18-07
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_23_APP-K_10-04-12
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_24_APP-L_4-27-10
- OMM-0039_0D_GF-117_BMK3.0-DF_G-11-0708 and UP_25_WARR_2-4-08