Hearth and Home Technologies Santa Fe Pellet Insert SANTAFEI-B User Manual
Page 3
R
September 1, 2008
7019-205C
Page 3
Santa Fe Pellet Insert
Section 1: Listing and Code Approvals
A. Appliance
Certifications
......................4
B. Mobile Home Approved ......................4
C.
Glass
Specifications
............................4
D.
Electrical
Rating
..................................4
E. BTU & Efficiency Specifications ..........4
Section 2: Getting Started
A. Design, Installation & Location
Considerations
....................................5
B. Locating Your Appliance & Chimney ..6
C.
Draft
....................................................6
D.
Negative
Pressure
..............................6
E.
Fire
Safety
..........................................7
F. Tools & Supplies Needed ...................7
G. Inspect Appliance, Components
and Pre-Check List .............................7
Section 3: Dimensions & Clearances
A. Appliance
Dimensions
........................8
B. Clearances to Combustibles
As A Built-In, UL and ULC ..................9
C. Clearances to Combustibles,
Masonry & Zero Clearance .................10
D.
Floor
Protection
..................................10
E. Minimum Opening for Factory
Built
Fireplace
.....................................10
F. Removing Floor of Factory Built
Fireplace
.............................................11
Section 4: Vent Information
A.
Chimney & Exhaust Connections
........12
B. Venting Termination Requirements ....12
C. Equivalent Feet of Pipe.......................13
D. Pipe Selection Chart ...........................13
Section 5: Venting Systems
A. Direct Connect with Outside Air ..........14
B. Direct Connect without Outside Air .....14
C. Full Reline with Outside Air .................15
Section 6: Mobile Home
..................................16
Section 7: Appliance Set-Up
A.
Leveling
System
.................................17
B. Outside Air Kit .....................................17
C.
Grille
Installation
.................................18
D. Door Handle Installation .....................19
E. Door Trim Installation ..........................19
F.
Door
Removal
.....................................19
G. Adjustable Hearth Support ..................20
H. Panel & Trim .......................................21
I.
Log Set Placement ..............................22
J.
Thermostat
Installation
........................23
Section 8: Operating Instructions
A. Fuel Size & Material ............................24
B. General Operation Information ...........24
C. Before Your First Fire .........................25
D. Starting Your First Fire ........................25
E. Fire Characteristics .............................25
F. Feed Rate Adjustment .......................25
G.
Ignition
Cycles
....................................26
H. Frequently Asked Questions...............26
Section 9: Troubleshooting
............................27-29
Section 10
:
Maintaining & Servicing Appliance
A. Proper Shutdown Procedures .............30
B. Quick Reference Maintenance Chart ..30
C. General Maintenance & Cleaning .......30-33
D. High Ash Content Maintenance ..........34
E.
Blower
Replacement
...........................35
F. Igniter
Replacement
............................36
G. Glass
Replacement
.............................36
H. Baffle & Brick Removal .......................37-38
Section 12: Reference Material
A. Component
Functions.........................39-40
B.
Component
Locations
.........................41
C. Exploded
Drawings
.............................42-43
D. Service Parts & Accessories ...............44-46
E. Service & Maintenance Log ................47-48
F.
Homeowner’s
Notes
............................49
G.
Warranty
Policy
...................................50-51
H. Contact
Information
.............................52
TABLE OF CONTENTS