Bolens TRANSMATIC LAWN TRACTOR 660 - Manual (Page 13)

SECTION 5: OPERATING THE LAWN TRACTOR
A WARNING
AVOID SERIOUS INJURY OR DEATH
GO UP AND DOWN SLOPES, NOT ACROSS.
AVOiD SUDDEN TURNS.
DO NOT OPERATE THE UNIT WHERE (T COULD SLIP OR
IF MACHINE STOPS GOING UPHILL, STOP BLADE(S) AND
BACK DOWNHILL SLOWLY,
DO NOT MOW WHEN CHILDREN OR OTHERS ARE
AROUND,
NEVER CARRY CHILDREN, EVEN WITH BLADES OFF.
LOOK DOWN AND BEHIND BEFORE AND WHILE BACKING.
KEEP SAFETY DEVICES (GUARDS, SHIELDS, AND
SWITCHES) IN PLACE AND WORKING,
REMOVE OBJECTS THAT COULD BE THROWN BY THE
BLADE(S).
KNOW LOCATION AND FUNCTION OF ALL CONTROLS.
BE SURE BLADE(S) AND ENGINE ARE STOPPED BEFORE
PLACING HANDS OR FEET NEAR BLADE(S).
BEFORE LEAVING OPERATOR’S POSITION, DISENGAGE
BLADE(S), PLACE THE SHIFT LEVER IN NEUTRAL, ENGAGE
PARKING BRAKE, SHUT ENGINE OFF AND REMOVE KEY
HEAD OPERATOR’S MANUAL
Starting the Engine
Safety Interlock System
A
WARNING: Read, understand, and follow
ail instructions and warnings on the machine
and in this manual before operating.
This tractor is equipped with a safety interiock system
for the protection of the operator, if the interlock system
should ever malfunction, do not operate the tractor.
Contact an authorized service dealer. The safety
interiock system prevents the engine from cranking or
starting unless the parking brake is engaged, and the
deck engagement/iift lever is in the disengaged
(BLADES STOP) position.
* The engine will automatically shut off if the operator
leaves the seat before engaging the parking brake.
* The engine will automatically shut off if the operator
leaves the tractor’s seat with the deck engagement/
lift lever in ANY position other than BLADES STOP.
* The engine wiii automatically shut off if the deck
engagemenViift lever is moved out of the BLADES
STOP position with the shift iever in R (reverse).
Before Starting Engine
A
WARNING: Read, understand, and follow
all instructions and warnings on the machine
and in this manual before operating.
A
WARNING: Do not operate the tractor if the
interlock
system is malfunctioning. This
system was designed for your safety and
protection,
NOTE: Refer to the TRACTOR SET-UP on page 8 of this
manual for Gasoline and Oil fill-up instructions.
* Insert the tractor key into the ignition switch.
* Piece the deck engagement/iift iever in the
BLADES STOP position.
* Engage the tractor’s parking brake.
* Activate the choke control.
* Turn the ignition key clockwise to the START
position. After the engine starts, release the key. It
will return to the ON position.
IMPORTANT: Do NOT hold the key in the START
position for longer than ten seconds at a time. Doing so
may cause damage to your engine’s electric starter.
* After the engine starts, deactivate the choke control
and place the throttle control in the FAST position.
IMPORTANT: Do NOT leave the choke control on while
operating the tractor. Doing so will result in a "rich“ fuel
mixture and cause the engine to run poorly.
N GTE: If Starting problems are encountered, refer to
TROUBLE SHOOTING GUIDE on page 28.
Stopping the Engine
A
WARNING: If you strike a foreign object,
stop the engine, disconnect the spark plug
wire(s) and ground against the engine.
Thoroughly inspect the machine for any
damage. Repair the damage before restarting
and operating
If the blades are engaged, place the deck
engagement/iift iever in the BLADES STOP
position.
Depress the clutch-brake pedal to bring the tractor
to a complete stop.
Turn the ignition key counterciockwise to the OFF
position.
Engage the tractor’s parking brake.
Remove the key from the ignition switch to prevent
unintended starting.
13