Reznor R6GD Unit Installation Manual - Manual (Page 36)

7091470 (Replaces 7089850)
Specifi cations and illustrations subject to change
without notice or incurring obligations.
Printed in U.S.A. (01/10)
INSTALLATION/PERFORMANCE CHECK LIST
O'Fallon, MO 7091470
GAS SYSTEM:
Gas Type: (circle one)
Natural
Gas
Propane
Gas pipe connections leak-tested? YES NO
Gas Line Pressure: ____________________________ (in - W.C.)
Is there adequate fresh air
supply for combustion and
ventilation?
YES NO
Installation Altitude: ______________________________ (FT.)
Deration Percentage: ______________________________ (%)
Furnace Input: _________________________________(Btuh)
Supply Air Temperature: __________________________ (° F)
Return Air Temperature: __________________________ (° F)
Temperature Rise: _______________________________ (° F)
During Furnace Operation:
Low fi re manifold pressure: ______________________ (in - W.C.)
High fi re manifold pressure: ______________________ (in - W.C.)
REFRIGERATION SYSTEM:
Was unit given 24 hr warm up period
for crankcase heaters?
YES NO
Stage-1 Liquid Pressure (high side) ________________________
Stage-1 Suction Pressure (low side) ________________________
Stage-2 Liquid Pressure (high side) ________________________
Stage-2 Suction Pressure (low side) ________________________
INSTALLATION ADDRESS:
CITY ________________________ STATE ________________
UNIT MODEL # ________________________________________
UNIT SERIAL # _______________________________________
Unit Installed Minimum clearances per
Figure 2 (page 7)?
YES NO
INSTALLER NAME:
CITY _______________________ STATE ________________
Has the owner’s information been
reviewed with the customer?
YES NO
Has the Literature Package been left
with the unit?
YES NO
ELECTRICAL SYSTEM:
Electrical connections tight? YES NO
Line voltage polarity correct? YES NO
Rated Voltage: ___________________________________ VOLTS
L1-L2 Volts: _____________________________________ VOLTS
L1-L3 Volts: _____________________________________ VOLTS
L2-L3 Volts: _____________________________________ VOLTS
Avg. Volts: ______________________________________ VOLTS
Max. deviation of voltage from avg. volts: ______________ VOLTS
% Volt imbalance: ________________________________ VOLTS
Blower Motor HP: ________ Sheave Setting ___________# Turns
Has the thermostat been calibrated? YES NO
Is the thermostat level? YES NO
Is the heat anticipator setting correct? YES NO
VENTING SYSTEM:
Is the vent hood installed? YES NO
Is vent hood free from restrictions YES NO
Filter(s) secured in place? YES NO
Filter(s) clean? YES NO
IMPORTANT - This product has been designed and manufactured to
meet ENERGY STAR criteria for energy effi ciency. However, proper
refrigerant charge and proper air fl ow are critical to achieve rated
capacity and effi ciency. Installation of this product should follow the
manufacturer’s refrigerant charging and air fl ow instructions. Failure to
confi rm proper charge and airfl ow may reduce energy effi ciency and
shorten equipment life.
¢7091479¤