Note, Leak testing valves, hose and regulator, Iturn all grill control knobs to off – Kenmore 146.1622201 User Manual

Page 6: Danger f

Attention! The text in this document has been recognized automatically. To view the original document, you can use the "Original mode".

Turn the coupling nut clockwise and tighten to a full stop. The

regulator will seal on the back-check feature in the LP tank
valve, resulting in some resistance.

An additional one-half

to three-quarters turn is required to complete the
connection. Tighten by hand only - do not use tools.

NOTE:

If you cannot complete the connection, disconnect regulator

and repeat steps 5 and 6. If you are still unable to complete the
connection,

do not use this regulator!

Call

1-800-4-WIY-HOIVIE@

for an identical replacement part.

DANGER

I • *

• Do not insert any tool or foreign object into the valve

outlet or safety relief valve. You may damage the valve
and cause a leak. Leaking propane may result in
explosion, fire, severe personal injury, or death.

: *

Outdoor gas appliance is not intended to be installed
in or on a boat.
Outdoor gas appliance is not intended to be installed
in or on an RV.
Never attempt to attach this grill to the self-contained
LP gas system of a camper trailer or motor home.

Do not use grill until leak-tested.
If a leak is detected at any time, STOP and call the fire

department.

If you cannot stop a gas leak, immediately close

LP cylinder valve and call LP gas supplier or your fire

department !

Leak Testing Valves, Hose and Regulator

ITurn all grill control knobs to OFF.

Be sure regulator is tightly connected to LP tank.

Completely open LP tank valve by turning OPD hand wheel

counterclockwise. If you hear a

rushing sound,

turn gas off

immediately. There is a major leak at the connection.

Correct

before proceeding

by calling Sears for replacement parts at

1-800-4-WIY-HOIVIE@.

Brush soapy solution onto areas where bubbles are shown in

picture below:

▲ iever remo'vo threaded

OTifice at end of valve.

5. If “growing”

bubbles appear, there is a leak. Close LP tank

valve immediately and retighten connections.

If leaks cannot

be stopped do not try to repair.

Call Sears for replacement

parts at

1-800-4-WIY-HOIVIE@.

Always close LP tank valve after performing leak test

by turning hand wheel clockwise.

6 -640-01303702-3-58