Banner Q45 Series - Manual (Page 3)

The Q45X sensor with 45DN expansion card installed requires DeviceNet-compatible
quick-disconnect cable, which is available from various manufacturers, such as
interlinkBT. See table at left.
Q45XDN
™
P/N 39667 rev. C
3
Banner Engineering Corp. • Minneapolis, MN U.S.A.
www.bannerengineering.com • Tel: 763.544.3164
Q45X Base, Male Connector
Hookup
Figure 3. Q45X Bus Configuration (45DN card installed)
1
5
4
3
2
Shield
Communications -
Communications +
BUS power (-V)
BUS power (-V)
Blue
White
Black
Red
Pin Function
Wire
Color*
*Wire colors in the table above are for
DeviceNet-compatible cable only.
Specifications – Q45X Series Sensors using 45DN Expansion Cards*
Supply Protection Circuitry Protected against reverse polarity, transient voltages and loss of ground
(none of these conditions will harm the sensor or interrupt communication on the network)
Response Time 2 milliseconds; total response time will also include the response time of the network
Indicators On the sensor: Green and Red; visible through the transparent sensor top cover
Green LED lights for dc power “ON”
Red LED(except emitter model Q45X6EQ) is Banner's patented Alignment Indicating Device (AID ™ ,
U.S. patent #4356393) which lights whenever the sensor “sees” a light condition and superimposes a
pulse rate which is proportional to the strength of the received light signal (the stronger the signal, the
faster the pulse rate)
On the 45DN1 and 45DN2 Bus Cards: Green and Red; visible through the transparent sensor top cover
A bi-color LED indicates the status of the network.
Green
Steady Sensor on line, connected to master
Flashing Sensor on line - address + baud rate are ok
Red Steady Critical network fault or duplicate node address detected; wrong baud rate
Flashing Minor or connection time-out fault
Operating Conditions Temperature: -10° to +70°C (-14° to +158°F)
Relative humidity: 95% (non-condensing)
Supply Voltage and Current 11 to 25V dc @ 60 mA (combined current for Q45X sensor and 45DN card)
5
4
1
2
3
* See Q45X datasheet P/N 37735 for further information.