Multiquip DCA45SSIU4F - Manual (Page 37)

dca45SSIU4F 60 hz generator• operatIon manUal — rev. #0 (09/09/14) — page 37
MaiNteNaNCe
general InSpectIon
Prior to each use, the generator should be cleaned and
inspected for deficiencies. Check for loose, missing or
damaged nuts, bolts or other fasteners. Also check for
fuel, oil, and coolant leaks. Use Table 14 as a general
maintenance guideline Engine Side (Refer to the Engine
Instruction Manual).
aIr cleaner
Every 250 hours: Remove air cleaner element (Figure 50)
and clean the heavy duty paper element with light spray of
compressed air. Replace the air cleaner as needed.
air cleaner with dust Indicator
This indicator (Figure 50) is attached to the air cleaner.
When the air cleaner element is clogged, air intake
restriction becomes greater and the dust indicator signal
shows REd meaning the element needs changing or
service. After changing the air element, press the dust
indicator button to reset the indicator.
Figure 50. Air Cleaner/Indicator
If the engine is operating in very dusty or dry grass
conditions, a clogged air cleaner will result. This can lead to
a loss of power, excessive carbon buildup in the combustion
chamber and high fuel consumption. Change air cleaner
more frequently if these conditions exist.
NOTICE
The air filter should not be changed until the indicator
reads “REd”. Dispose of old air filter. It may not be
cleaned or reused..
FUel addItIon
Add diesel fuel (the grade may vary according to season
and locations).
Removing Water from the Fuel Tank
After prolonged use, water and other impurities accumulate
in the bottom of the tank. Occasionally inspect the fuel tank
for water contamination and drain the contents if required.
During cold weather, the more empty volume inside the
tank, the easier it is for water to condense. This can be
reduced by keeping the tank full with diesel fuel.
cleaning Inside the Fuel Tank
Drain the fuel inside the fuel tank completely. Using a spray
washer (Figure 51) wash out any deposits or debris that
have accumulated inside the fuel tank.
Figure 51. Fuel Tank Cleaning