Multiquip 500kW Containerized Diesel Generator Set EGC-500C - Manual

500kW Containerized
Diesel Generator Set
Model Emissions Standby Rating Prime Rating
EGC-500C EPA Certified
60 Hertz
500kW (625kVA) 450kW (562.5kVA)
Standard Features
Cummins Heavy Duty Diesel Engine
„
4-cycle design, turbocharged, aftercooled, direct injection
„
Polymide blade cooling fan
„
Engine coolant heater
„
Meets EPA Tier 2 emissions standards
Fuel System
„
800 gallon, single wall fuel tank
„
Fuel priming system
„
Fuel/water separators and drip pan
„
Electric fuel run pump
„
External fuel fill
„
30 micron Racor ® fuel filter system
Alternator
„
Brushless, 4-pole, synchronous, WYE connection
„
Class H insulation system conforms to NEMA MG1-22, BS5000,
CSA-C22-2, IEC-34-1 standards for temperature rise
„
Drip-proof, self-venting, amortisseur windings
„
Epoxy impregnated windings with tropical insulation for increased
environmental protection and long life
Electronic Voltage Regulator
„
Electronic automatic voltage regulator provides precise regulation
„
Separate three-phase excitation for fast recovery from block loads
and motor starting
Full Load Acceptance
„
Accepts 100% of standby nameplate rating in one step, in compliance
with NFPA, para 5-13.2.6
Generator Control Panel
„
Basler vibration-isolated controller
„
Manual or remote engine start/stop
„
RS485/Modbus communication support
„
Safety shutdowns
„
Externally mounted emergency stop switch
„
Generator mainline circuit breaker, 100% rated, electronically
operated, UL listed
Specially Designed Container
„
20 ft. ISO container, sound-attenuated, foam-lined for extremely quiet
operation
„
Solidly mounted battery rack and cooling system
„
Intregral vibration isolators
„
Exterior polyurethane coating system provides long life in extreme
operating conditions
„
Interior DC lights and timer switch
„
Crankcase filtration system
„
Critical grade silencer with heat blankets
Warranty
„
Engine-generator sets are covered by an express written, one-year
limited warranty
(Shown with optional ISO trailer chassis)
EGC500C Rev 0